CarRecallWatchJuly 17, 2023
Loose Axle U-Bolts Can Shift Axle, Risking Crash
Grand Design Momentum 2021–2024Grand Design Solitude 2021–2024
Certain fifth wheel trailers have U-bolts that may have been improperly tightened.
Fuel Hose Clamp May Leak Gasoline, Creating Fire Risk
Maxvan Pathway 2020–2023Maxvan Route 2021
A fuel hose between the inline fuel filter and the Injection Pump Module in the vehicle's generator set may have inadequate clamp force, which could allow gasoline to leak.
Trailer Tires May Lose Pressure Above 45 mph
Kidron Refrigerated Trailer 2022
Certain 2022-2023 Kidron refrigerated trailers equipped with the Tire Pilot Plus tire pressure regulation system may lose air pressure in all eight tires while being driven faster than 45 mph.
Gas Leak Near Generator Can Raise Fire Risk
Pleasure WAY Lexor 2021–2023Pleasure WAY Ontour 2021–2023
The fuel hose between the inline fuel filter and the injection pump module in the generator may not have enough clamp force.
Leaf May Speed Up Unexpectedly After Changing Drive Mode
Nissan Leaf 2018–2023
Some 2018-2023 Nissan Leaf vehicles can accelerate on their own if the driver changes the driving mode (from D to B, turning e-Pedal on, or switching to ECO mode) after turning off cruise control.
July 14, 2023
Coolant Leak Can Increase Fire Risk in Engine Bay
Mclaren 600LT 2019–2020
A joint between the temperature sensor housing and the hose from the outboard radiator may not be sealed properly.
HVAC Blower Wiring Can Overheat and Cause a Fire
Entegra Launch 2020–2021Entegra Qwest 2020–2021Jayco Melbourne 2020–2021+1 more model
The HVAC front blower motor circuit in these motorhomes may be undersized, which can allow the wiring harness to overheat.
Rearview camera may flicker or distort, reducing rear view
Mazda CX-3 2016–2021Mazda MAZDA3 2014–2018
The rearview camera image may flicker or appear distorted on the display screen.
Front Seat Belts May Detach in a Crash
Tesla Model S 2021–2023Tesla Model X 2021–2023
Certain front-row seat belts may not be properly connected to the pretensioner anchors, which means the belt can come loose from its attachment point.
Forward Camera May Misalign, Disabling Automatic Braking Without Warning
Tesla Model S 2023Tesla Model X 2023Tesla Model Y 2023
The forward-facing camera on certain 2023 Model S, Model X, and Model Y vehicles may be misaligned.
July 13, 2023
Fuel Hose Leak Can Cause Fire in Surveillance Trailers
MVT-900A MVT-3001-G 2021
A fuel hose between the inline fuel filter and the Injection Pump Module on the generator set may not be clamped tightly enough.
July 12, 2023
Front Ball Joint May Disconnect, Causing Loss of Steering
Polestar Polestar 2 2023
A front left lower ball joint may have been installed incorrectly, which could allow the suspension control arm to come loose from the steering knuckle.
Windshield Wipers May Fail, Reducing Driver Visibility
Entegra Accolade 2021–2022Entegra Accolade XL 2021–2022Jayco Seneca 2021–2022+1 more model
Certain 2021-2022 motorhomes have windshield wiper linkages that may fail, causing the wipers to stop working properly and reducing the driver's view of the road in rain or other bad weather.
Plug-in hybrid DC-DC converter may short and cause fire
Toyota RAV4 Prime 2021–2022Lexus NX450H+ 2022
A component in the DC-DC converter, the unit that steps down high-voltage battery power for the vehicle's low-voltage systems, may have been damaged during production.
Dashboard control bar may fail to run defrost or hazard lights
BMW 740i 2023BMW 760i 2023BMW I7 2023
The Interaction Bar on the dashboard of certain 2023 BMW 740i, 760i xDrive and i7 xDrive60 vehicles may not activate the windshield defrost/defog system or the hazard warning lights when pressed.
Driver's air bag may be disabled, raising injury risk in a crash
Lexus NX Hybrid 2023–2024Lexus NX250 2023–2024Lexus NX350 2023–2024+9 more models
A weld inside the steering column's spiral cable assembly may be insufficient, so the electrical connection can separate.
Power Steering Hose Can Detach, Causing Sudden Loss of Steering Assist
Nova Bus LFS 2022–2023
Certain 2022-2023 transit buses may have had a power steering hose assembled incorrectly during manufacturing.
Transit Bus Driveshaft Can Separate, Causing Power Loss
Nova Bus LFS 2019–2023Nova Bus LFS Artic 2019–2023
Some transit buses may have a transmission yoke that can separate, causing the driveshaft to come loose and the bus to suddenly lose drive power.
July 11, 2023
Right front turn signal may fail, reducing warning to other drivers
Prevost H3-45 VIP 2022–2024Prevost H3-45 2023–2024
The right front turn signal light may fail when the turn signal or hazard warning lights are turned on.
Loose Seat Bolt Can Leave Passenger Seatbacks Unsecured
Prevost X3-45 Commuter 2021, 2023
A bolt securing the passenger seat recline mechanism on certain buses may loosen and come apart, leaving the seat back unsecured.
Tire valve stem may leak air, risking tire failure
Toyota RAV4 2023
Certain vehicles were fitted with 17-inch black alloy accessory wheels that may have had the tire valve stem improperly installed or damaged during installation.
July 10, 2023
Knee airbag may not deploy properly, raising injury risk
BMW X5 2024BMW X6 2024BMW X7 2024+1 more model
Certain BMW SUVs and the XM were built with a knee airbag (driver and/or passenger) that may not have been manufactured correctly.
Front brake caliper bolts may strip threads, risking brake loss
Yamaha Tenere 700 2022
The front brake calipers on this motorcycle may have been assembled with bolts of incorrect thread length.
Stove Burner Tubes Can Crack and Leak Gas, Creating Fire Risk
Boreas Camper XT 2021–2022
Certain SDS2 2-burner drop-in cooktops installed in these travel trailers have internal aluminum burner tubes that connect to the gas valves.
July 7, 2023
Spare Tire Chain May Break, Allowing Spare to Detach
Toyota Sequoia Hybrid 2023Toyota Tundra 2023Toyota Tundra Hybrid 2023
The steel chain that holds the spare tire to the underside of certain 2023 Toyota Tundra, Tundra Hybrid, and Sequoia Hybrid vehicles may not have been welded sufficiently.
Dinette Seat Belts May Fail to Restrain Occupants
Newmar BAY Star 2019–2023Newmar BAY Star Sport 2020–2023Newmar Super Star 2022–2023
Certain motorhomes have dinette seat belt mounting brackets that were modified to clear slide-out rollers in the floor.
July 6, 2023
Sudden Loss of Drive Power Can Increase Crash Risk
Freightliner E-Cascadia 2023–2024
Certain 2023-2024 Freightliner eCascadia trucks may have an e-axle planetary gear set that was not welded properly.
July 3, 2023
Loose Wiper Arm Nuts Can Disable Windshield Wipers
Mack LR 2023–2024
Certain garbage trucks are affected because the nuts that hold the windshield wiper arms in place may be loose or stripped.
Rearview Camera May Freeze or Go Blank in Reverse
Polaris Slingshot SL 2020–2023Polaris Slingshot R 2020–2022Polaris Slingshot S 2021–2023+4 more models
After the vehicle is shifted out of reverse, the rearview camera image can freeze, and it may show a blank screen when reverse is selected again.
June 30, 2023
Transmission Cooler Leak Can Cause Power Loss
E-One Cyclone II 2022–2023E-One Cyclone N 2022–2023E-One Typhoon N 2022–2023
The transmission cooler on certain vehicles may not be welded properly.