CarRecallWatchThe 2019 Ford F-250 SD has 11 safety recalls on file with NHTSA.
Owners have filed 1,165 complaints with NHTSA, including 16 crashes, 11 fires, 12 injuries.
The most-reported problem area is Steering (776 reports).
2019 Ford F-250 SD recalls
Rearview Camera May Show Blank or Distorted Image
The rearview camera can display a distorted, inverted, or blank image while the vehicle is in reverse.
Missing Head Restraint Instructions Raise Crash Injury Risk
Some Ford Expedition, Lincoln Navigator, and F-Super Duty SuperCab trucks were built without owner's manual instructions for adjusting or removing certain head restraints, including those for the center seating positions.
Foggy Rearview Camera Image Can Hide Hazards Behind You
This recall covers certain 2017-2018 Ford F-Super Duty trucks and Lincoln Continental sedans equipped with the 360-degree camera system.
Rearview camera may show blank or distorted image
Certain 2019 Ford F-150 and Super Duty F-250, F-350, F-450, and F-550 trucks may have a poor electrical connection in the rearview camera.
Loose Underbody Shield Can Damage Driveshaft, Risking Crash
Underbody heat and noise insulators on certain Super Duty pickups with gasoline engines and aluminum driveshafts may loosen and contact the driveshaft.
Tires May Fail, Causing Sudden Air Loss or Tread Separation
Certain Continental tires on these Ford trucks and SUVs may have been cured for too long during production.
Seat belt sparks can ignite interior materials, causing fire
Certain 2017-2019 Ford F-Super Duty SuperCrew Cab trucks have carpet flooring that can ignite if a front seat belt pretensioner fires during a crash.
Tailgate May Unlatch Unexpectedly, Dropping Cargo
Water can get into the electrical wiring of the tailgate release switch in the tailgate handle.
Daytime Running Lights May Not Dim, Raising Crash Risk
Some trucks in this recall may keep their daytime running lights at full brightness when the headlight switch is turned to the On position.
Damaged Engine Block Heater Cable Can Overheat and Cause Fire
Some pickup trucks with an engine block heater had a previous repair under an earlier recall.
Transmission May Not Hold Park, Risking Rollaway
A casting defect in the automatic transmission case on certain 2019 Ford F-250, F-350 and F-450 Super Duty trucks may prevent the park pawl assembly from being properly secured.
Most common 2019 Ford F-250 SD problems
Problem areas named in the 1,165 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Steering | 776 |
| Suspension | 678 |
| Unknown Or Other | 113 |
| Wheels | 87 |
| Power Train | 46 |
| Electrical System | 33 |
| Fuel/Propulsion System | 32 |
| Back Over Prevention | 31 |
| Structure | 21 |
| Engine | 21 |
What owners report
On October 9, 2026 at approximately 8:30 AM, my 2019 Ford F-250 6.7L Power Stroke diesel, with 76,512 miles, suffered a catastrophic high-pressure fuel injection pump failure while traveling approximately 55 mph on FM 3351 near Camp Stanley, Texas. The vehicle displayed âSpeed Limitedâ and âReduced Engine Powerâ warnings, then lost throttle response and propulsion and the engine shut down while moving. Steering and braking effort increased substantially after the engine stopped. The truck would crank but would not restart. Alamo Diesel Service, an independent diesel repair facility, confirmed no fuel-rail pressure, fuel leaking in the engine valley, and that the injection pump had â
NHTSA Vehicle Safety Complain To whom it may concern, My Name is [XXX] I am submitting this complaint regarding my 2019 Ford F-250 Super Duty equipped with the 6.7L Power Stroke diesel engine (VIN: [XXX]). At approximately 137,900 miles, my vehicle suddenly lost engine power while driving and stalled without warning, creating a serious safety hazard. After stalling, the truck would not restart and had to be towed to a repair facility. The repair shop diagnosed a catastrophic failure of the diesel high-pressure fuel injection pump. According to the repair invoice, fine metallic flakes were found throughout the entire fuel system, contaminating the fuel lines, fuel tank, injectors, and related
The contact owns a 2019 Ford F-250 SD. The contact stated that while driving 70 MPH, there was an abnormal diesel odor on the inside of the vehicle. The contact stated that the vehicle failed to exceed 65 MPH, and there was white to gray smoke coming from under the hood. The contact pulled over with the engine still running and after opening the hood, the contact became aware of diesel fuel squirting out from the secondary fuel filter. The contact stated that the fire consumed the vehicle. The fire was coming from underneath the driver's side hood and driverâs side wheel well. The Fire Department was contacted and extinguished the fire coming from the vehicle. The vehicle was towed to an i
I experienced a severe, violent, and uncontrollable front-end suspension and steering wheel oscillationâcommonly known as the "Ford Super Duty Death Wobble." While traveling at highway speeds approximately 70mph, I came across a bridge expansion joint (nothing unusual) and immediately upon impacting the joint, the front axle began shaking so violently that it caused a sudden, near-total loss of steering control. The violent shaking made it nearly impossible to maintain a straight lane of travel, risking a catastrophic multi-vehicle collision. The steering wheel jerked violently side-to-side, forcing me to rapidly and dangerously decelerate in active highway traffic to regain control of the
I am filing a complaint against Capital Auto Mall Premier regarding the sale of a 2019 Ford F\-250 Lariat \(VIN [XXX]\) that I purchased on XXX. The vehicle was represented as being in good working condition at the time of sale. However, almost immediately after taking possession of the vehicle, I began discovering numerous mechanical, electrical, and safety\-related defects. Due to the number of concerns, I had the vehicle independently inspected shortly after purchase. The inspection identified multiple significant issues, including transmission hard shifting, transfer case clunking during shifting, battery failure requiring replacement, steering and suspension concerns, excessive play i
2019 Ford F-250 SD questions
Does the 2019 Ford F-250 SD have any recalls?
Yes. NHTSA lists 11 safety recalls for the 2019 Ford F-250 SD: Rearview Camera May Show Blank or Distorted Image; Missing Head Restraint Instructions Raise Crash Injury Risk; Foggy Rearview Camera Image Can Hide Hazards Behind You; Rearview camera may show blank or distorted image; Loose Underbody Shield Can Damage Driveshaft, Risking Crash. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2019 Ford F-250 SD?
Based on 1,165 owner complaints filed with NHTSA, the most-reported problem areas are Steering (776), Suspension (678), Unknown Or Other (113).
How do I check if a recall on my 2019 Ford F-250 SD has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.