2012 Ford F-250 SD Recalls, Problems & Safety Rating

2012 Ford F-250 SD recalls

No safety recalls on file for the 2012 Ford F-250 SD.

Most common 2012 Ford F-250 SD problems

Problem areas named in the 57 complaints owners filed with NHTSA.

Problem area	Reports
Steering	18
Engine	15
Suspension	14
Engine And Engine Cooling	13
Electrical System	10
Fuel/Propulsion System	4
Service Brakes	4
Power Train	3
Wheels	3
Unknown Or Other	3

What owners report

2023-02-27, Steering
Ford super duty has been in shop for death wobble numerous times and when we get vehicle back still is the issue. Very unsafe and hard to stable once it starts. Even auto shop people when thought fixed drove and scared them. Whole truck shakes uncontrollably. Very poor on Ford for no recall with this happening. Why buy truck if you can’t drive it for work duties.

2020-01-08, Steering
WHILE TRAVELING EAST BOUND ON INTERSTATE 10 CROSSING OVER SIEGEN LANE, TRUCK PASSED OVER SMALL BUMP IN INTERSTATE AND STARTED TO VIOLENTLY SHAKE THE ENTIRE TRUCK ALMOST TO THE POINT OF NO CONTROL. I IMMEDIATELY PULLED OVER TO INSPECT MY TRUCK. THERE WAS NO DAMAGE AND ALL TIRES WERE IN GOOD CONDITION. WHEN I STARTED AGAIN THE VEHICLE WAS FINE. THIS WAS THE FIRST OF 12 INCIDENTS OF WHAT I HAVE COME TO KNOW FROM RESEARCH AS THE "DEATH WOBBLE". I HAVE TAKEN MY TRUCK THE THE FORD DEALERSHIP ON NUMEROUS OCCASIONS AND HAVE SPENT THOUSANDS OF DOLLARS TO CORRECT THE ISSUE TO NO AVAIL. THE PROBLEM PERSISTS AND FORD CANNOT FIGURE OUT THE ISSUE. THIS IS THE MOST UNNERVING EXPERIENCE. THIS WAS A $70000 V

2019-07-25, Steering
VEHICLE MILEAGE APPROXIMATELY 70,000. AT SPEEDS BETWEEN 35-65 MPH ANY MINOR BUMP WILL CAUSE TRUCK TO BEGIN TO VIBRATE THROUGHOUT THE STEERING SYSTEM AND SUBSEQUENTLY WOBBLE VIOLENTLY. APPLYING THE BRAKES MAKES IT WORSE UNTIL THE TRUCK SLOWS DOWN BELOW 35MPH. THE TRUCK IS NOT ABLE TO BE STEERED DURING THIS EVENT. I HAVE TAKEN IT TO SEVERAL REPUTABLE MECHANICS AND THEY HAVE ASSURED ME THIS DISCREPANCY IS IN MANY F-250S AND NO ONE HAS THE COMPLETE SOLUTION. I CONTACTED FORD MOTOR COMPANY CUSTOMER SERVICE AND THEY HAVE NO INTEREST OR EXPECTATION OF A RECALL. THEY DID TELL ME TO TAKE IT TO A FORD DEALERSHIP FOR REPAIR. THE LOCAL FORD DEALERSHIP GAVE ME A QUOTE TO REPLACE- TIE RODS, TIE RO

2019-05-08, Steering
ON HIGHWAY DRIVING ABOUT 55 MPH LOST CONTROL OF VEHICLE NO DEATH WOBBLE THEY SPEAK OF BUT WENT INTO NEXT LANE OVER AND COULD NOT CONTROL TRUCK UNTIL SPEED WAS LOWER. THIS HAPPENED AT LEAST THREE TIMES ALREADY SENT IT INTO SHOP FRONT END TIGHT HAD ALL THE TIRES REPLACED FRONT END ALIGNED STILL PULLS LEFT AND RIGHT.

2019-04-13, Steering
DEATH WOBBLE - HAVE BEEN EXPERIENCING VIOLENT SHAKING AND INSTABILITY WHILE AT SPEEDS OF 55-65 MPH. STEERING WHEEL CAN ALMOST BE SHAKEN OUT OF MY HANDS WITH A TIGHT GRIP. SOLUTION IS TO SLOW TO BELOW 25MPH. THEN START OVER. WOBBLE STARTS SOMETIMES ON ITS OWN OR IF HITTING SMALL UNEVEN SURFACE SUCH AS BRIDGE/ROAD JOINT.

2012 Ford F-250 SD questions

Does the 2012 Ford F-250 SD have any recalls?

No. NHTSA has no safety recalls on file for the 2012 Ford F-250 SD at this time.

What are the most common problems with the 2012 Ford F-250 SD?

Based on 57 owner complaints filed with NHTSA, the most-reported problem areas are Steering (18), Engine (15), Suspension (14).

How do I check if a recall on my 2012 Ford F-250 SD has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.