CarRecallWatchThe 2018 Ford F-250 SD has 9 safety recalls on file with NHTSA.
Owners have filed 400 complaints with NHTSA, including 7 crashes, 9 fires, 4 injuries.
The most-reported problem area is Steering (253 reports).
2018 Ford F-250 SD recalls
Rearview Camera May Show Blank or Distorted Image
The rearview camera can display a distorted, inverted, or blank image while the vehicle is in reverse.
Driveshaft may fracture, causing loss of power or rollaway
A radial damper inside the driveshaft can move out of position over time.
Foggy Rearview Camera Image Can Hide Hazards Behind You
This recall covers certain 2017-2018 Ford F-Super Duty trucks and Lincoln Continental sedans equipped with the 360-degree camera system.
Loose Underbody Shield Can Damage Driveshaft, Risking Crash
Underbody heat and noise insulators on certain Super Duty pickups with gasoline engines and aluminum driveshafts may loosen and contact the driveshaft.
Tires May Fail, Causing Sudden Air Loss or Tread Separation
Certain Continental tires on these Ford trucks and SUVs may have been cured for too long during production.
Seat belt sparks can ignite interior materials, causing fire
Certain 2017-2019 Ford F-Super Duty SuperCrew Cab trucks have carpet flooring that can ignite if a front seat belt pretensioner fires during a crash.
Tailgate May Unlatch Unexpectedly, Dropping Cargo
Water can get into the electrical wiring of the tailgate release switch in the tailgate handle.
Daytime Running Lights May Not Dim, Raising Crash Risk
Some trucks in this recall may keep their daytime running lights at full brightness when the headlight switch is turned to the On position.
Damaged Engine Block Heater Cable Can Overheat and Cause Fire
Some pickup trucks with an engine block heater had a previous repair under an earlier recall.
Most common 2018 Ford F-250 SD problems
Problem areas named in the 400 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Steering | 253 |
| Suspension | 199 |
| Unknown Or Other | 46 |
| Wheels | 29 |
| Structure | 16 |
| Power Train | 16 |
| Engine | 15 |
| Fuel/Propulsion System | 13 |
| Back Over Prevention | 10 |
| Electrical System | 9 |
What owners report
I recently purchased this vehicle and have had the "death wobble" occur 3 times recently. Driving at normal conditions, hit a bump in the road and the front wheels violently start shaking and the vehicle must come to a complete stop to stop the shaking. I had a semi behind me last time and was almost rear ended. This is a huge concern, and I've read where Ford refuses to address the issue as it is expensive to repair. I am formerly declaring that if this causes an accident it is on record that I have expressed my concerns and l will hold Ford liable.
When having to brake hard such as when a deer runs out my trucks ABS does not activate and my tires lock up causing me to slide. This has happened several times over the past few months . there are no ABS dtc codes and I have consulted technicians to no avail. I will note the last incident below but it has happened repeatedly.
The contact owns a 2018 Ford F-250 SD. The contact stated that while driving, the vehicle was vibrating abnormally. The contact researched and became aware of NHTSA Campaign Number: 22V087000 (Structure, Power Train); however, the VIN was not included in the recall. The manufacturer was notified of the failure. The failure mileage was 85,000.
Truck started loosing power And caught fire at the red light
Low fuel pressure alert came on the truck. It went away and then came on again a few days later. We took the truck to Joe Meyers Ford in Houston, TX. They verified the code/alert and replaced the fuel filter, then re-tested. The alert returned and once they continued their diagnosis, it was determined that the fuel pressure control valve had failed, allowing fuel, DEF, and water into the fuel filter. The fuel pressure would no increase to minimum spec of 55 psi. Ford then said that without replacing the Fuel Pressure Control Valve, Fuel pump, fuel filters, and flushing all the lines, the risk for the engine to seize up was very likely. They noted this was a similar issue happening to
2018 Ford F-250 SD questions
Does the 2018 Ford F-250 SD have any recalls?
Yes. NHTSA lists 9 safety recalls for the 2018 Ford F-250 SD: Rearview Camera May Show Blank or Distorted Image; Driveshaft may fracture, causing loss of power or rollaway; Foggy Rearview Camera Image Can Hide Hazards Behind You; Loose Underbody Shield Can Damage Driveshaft, Risking Crash; Tires May Fail, Causing Sudden Air Loss or Tread Separation. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2018 Ford F-250 SD?
Based on 400 owner complaints filed with NHTSA, the most-reported problem areas are Steering (253), Suspension (199), Unknown Or Other (46).
How do I check if a recall on my 2018 Ford F-250 SD has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.