CarRecallWatchSeptember 24, 2021
Bus Electrical Panel Can Fail, Causing Fire or Shutdown
MCI J4500 2017–2021MCI D45 CRT LE 2018–2021MCI D4500 2017–2020+6 more models
The Main Distribution Panel in the battery compartment of these motorcoaches contains a circuit board that may fail.
Turn Signal May Blink the Wrong Way, Raising Crash Risk
Hyundai Sonata 2015–2017Hyundai Sonata Hybrid 2016–2017Hyundai Sonata Plug-IN Hybrid 2016–2017
Certain vehicles have a software logic problem in the Smart Junction Box that may not correctly read signals from the multifunction switch.
September 23, 2021
Incorrect roof reinforcement may weaken crash protection
Volkswagen Tiguan 2018
An incorrect roof reinforcement assembly may have been installed during repair of roof damage.
Brake caliper clips may bend, risking loss of braking
DRV Elite Suite 2018–2021DRV Mobile Suite 2018–2021DRV Mobile Suites 2021
On certain 2018-2021 DRV Elite Suite and Mobile Suite fifth wheel trailers, the brake caliper retaining clips may bend or warp during braking.
Cracked Mounting Frame Could Separate From Truck
Altec Aerial Device 2011–2016
Cracks may develop in the legs of the mounting frame on certain 2011-2016 AT200A aerial devices.
Wheelchair Lift Barrier May Fail, Risking Rider Injury
MCI J4500 2005–2012MCI E4500 2005–2009
The outer barrier of the wheelchair lift on these motorcoaches may not withstand enough force when fully deployed.
Side Stand May Break, Causing Motorcycle to Fall
Ducati Hypermotard 2019
Certain 2019 Ducati Hypermotard motorcycles may have a side stand that was improperly welded.
Fuel Pump Module May Fail, Causing Engine Stalls
Cadillac Escalade 2021Cadillac Escalade ESV 2021Cadillac Escalade NA 2021+4 more models
The fuel pump power control module in these vehicles can cause the fuel pump to fail or run intermittently.
Wiring and oxygen tubing can rub and cause fire
Demers Ambulances MXP153 Ford F-Series 2020–2021Demers Ambulances MXP153 Dodge RAM 2020
Certain Demers MXP153 ambulances on Dodge Ram and Ford F-Series chassis may have ceiling spacers that do not leave enough clearance for the electrical wires and the medical oxygen tube.
Corroded CNG Fuel Connector Can Cause Fire Risk
Thomas Built Buses Minotour 2015–2018
A connector on the under-body CNG fuel shut-off solenoid, which links to the compressed natural gas fuel tank, may corrode over time.
Third-Row Headrests May Move or Detach in a Crash
Nissan Pathfinder 2022
Certain 2022 Nissan Pathfinder vehicles have third-row headrests that may have an improper weld or misaligned internal components.
Rear seat backs may separate, risking crash protection
Nissan Pathfinder 2022
Some 2022 Nissan Pathfinder vehicles may have insufficient welds on the second-row seat back frames.
September 22, 2021
Hybrid System May Shut Down Without Warning, Losing Drive Power
Toyota Prius 2022Toyota Prius Prime 2022
The engine control software in these vehicles can falsely detect a fault and shut down the hybrid system while driving.
Rearview camera may fail to display image, raising crash risk
Ford Explorer 2020–2021Lincoln Aviator 2020–2021Lincoln Corsair 2020–2021
Certain 2020-2021 Ford Explorer and Lincoln Aviator and Corsair vehicles equipped with 360-degree cameras may have a rearview camera whose video output fails, so the camera image does not appear on the display.
Rear Suspension Part May Seize and Break, Causing Loss of Steering
Ford Explorer 2011–2013
Certain 2011-2013 Ford Explorers in specific Northeastern, Midwestern and Mid-Atlantic states may have a cross-axis ball joint (CABJ) replacement part in the rear suspension that could seize.
September 21, 2021
Turn signals may fail to warn drivers of bulb outage
RAM Promaster City 2019–2021
If one or both turn signal lights fail, the flashing rate may not change to alert the driver that a light has burned out.
Rearview camera may not display image, raising crash risk
Jeep Grand Cherokee 2021
A software error in the radio can prevent the rearview camera image from appearing on the screen.
Commercial Vans May Not Meet Federal Safety Standards
Workhorse Motor Works C1000M 2020–2021Workhorse Motor Works C1000S 2020–2021Workhorse Motor Works C650 2020
Certain commercial delivery vehicles may not comply with several federal motor vehicle safety standards covering instrument displays, windshield wipers and washers, exterior lighting, wheels and rims, and door locks.
September 17, 2021
Wrong tires can overload trailer and raise crash risk
Coachmen Aurora 2022
Certain 2022 Coachmen Aurora travel trailers were built with the wrong tires.
Loose Propane Fitting Can Leak Gas and Cause Fire
East TO West Alta 2022
Certain trailers have an LP gas quick disconnect fitting that may not have been properly tightened, which could allow propane gas to leak.
Turn Signal May Flash the Wrong Direction
Kia Sedona 2015–2017
Certain 2015-2017 Kia Sedona vehicles may have a software problem in the Smart Junction Box.
Loose Brake Rotor Bolts Can Cause Wheel Separation
DRV Mobile Suite 2021DRV Mobile Suites 2021
Certain 2021 DRV Mobile Suites fifth wheel trailers were built with brake rotor bolts that were improperly tightened.
Engine Bearings May Wear Out, Risking Stall or Fire
Hyundai Sonata Hybrid 2017Hyundai Tucson 2017
Connecting rod bearings inside the engine may wear prematurely, which can damage the engine.
September 16, 2021
Stability Warning Light May Not Light Up, Raising Crash Risk
Peterbilt 567 2022Peterbilt 579 2022
Certain 2022 Peterbilt 567 and 579 trucks may have an electronic stability control (ESC) software problem that keeps the ESC malfunction indicator lamp from turning on.
Rear brakes may release too slowly, raising crash risk
Peterbilt 520 2020–2021
A quick release valve on the rear brake signal hose may be missing.
Vacuum excavators may lack proper rear lights and reflectors
Mclaughlin Vacuum Excavator 2005–2021Vermeer Vacuum Excavator 2021
Certain vacuum excavators built between 2005 and 2012 may not have enough rear clearance lamps and reflex reflectors, including the rear-side versions.
Aerial Device Bolts May Break, Pedestal Could Separate
Altec Aerial Device 2016–2021
Certain 2016-2021 LS87 aerial devices may have rotation bearing bolt washers that interfere with an adjacent pedestal weld.
September 15, 2021
Loose Fan Belt Can Disable Bus, Forcing Evacuation
Thomas Built Buses Saf-T-Liner HDX 2022
The fan drive pulley assembly on certain 2022 Saf-T-Liner HDX school buses may have incorrect or improperly installed mounting bolts.
Exhaust Tip Can Melt Battery Box, Risking Fire
On certain 2022 heavy-duty trucks, the exhaust pipe outlet may have been installed with its tip facing the battery box mounted above the frame rail.
Brake Assist and ABS May Fail, Raising Crash Risk
Volvo XC60 2020–2021Volvo XC90 2020–2021Volvo S90 2021
A welding defect in the brake system's integrated hydraulic unit means the rotor and shaft can separate.