CarRecallWatchMay 9, 2025
Front Control Arm Can Detach, Risking Loss of Steering
Ford Bronco 2024–2025
The front lower control arm fasteners may not have been tightened properly, which could allow the control arm to detach from the frame.
Steering Shaft May Detach, Causing Loss of Steering
Ford F-150 2025
A steering component in certain vehicles may not be properly attached.
Front Control Arm May Detach, Risking Loss of Steering
Ford Bronco 2024–2025Ford Ranger 2024–2025
A front upper control arm ball joint fastener may be missing or improperly tightened.
Driver's seat may lack secure bolts, raising crash injury risk
Ford Bronco 2025Ford Ranger 2025
Some 2025 Ford Bronco and Ranger vehicles may have loose or missing bolts securing the driver's seat frame to the vehicle body.
Rearview camera image can stay on after reversing, distracting driver
Ford Bronco 2021–2022
Some Ford Bronco vehicles from 2021 and 2022 have 8-inch SYNC infotainment screens that were repaired incorrectly under an earlier recall.
ESC May Stay Off After Restart, Raising Crash Risk
Ford F-150 Lightning BEV 2022–2023
Some 2022-2023 Ford F-150 Lightning electric trucks may not turn on the electronic stability control (ESC) system at the start of each drive.
Brake Line May Rub Air Duct, Causing Fluid Leak
Ford Expedition 2022–2024Lincoln Navigator 2022–2024
Front brake lines can contact the engine air cleaner outlet pipe over time.
Rearview Camera May Freeze or Go Blank in Reverse
Ford Bronco 2021–2024Ford Edge 2021–2024Ford F-150 2021–2024+14 more models
A software error in the accessory protocol interface module (APIM) can cause the rearview camera image to lag, freeze, or fail to display when the vehicle is in reverse.
Loose Front Subframe Bolt Could Weaken Crash Protection
Ford Explorer 2025Lincoln Aviator 2025
Some 2025 vehicles may have a front subframe mounting bolt that was not tightened correctly at the factory.
May 8, 2025
Rearview camera may not display in reverse, raising crash risk
Volvo XC40 2021–2025Volvo C40BEV 2022–2025Volvo S90 2022–2025+9 more models
The rearview camera image may fail to appear when the vehicle is put in reverse.
Gear Display May Show Wrong Gear, Risking Crash
Certain trucks have a software error that can make the gear selection display inaccurate.
Driver's Air Bag May Not Deploy Properly in a Crash
RAM 1500 2019–2024
Some 2019-2024 Ram 1500 trucks may have a driver's side air bag that is not connected properly.
Front Passenger Headrest May Be Poorly Welded, Raising Crash Injury Risk
Chevrolet Express 2025GMC Savana 2025
Certain 2025 Chevrolet Express and GMC Savana vans may have a front passenger seat head restraint that was improperly welded to the seat frame.
Side Curtain Airbags May Not Stay Inflated in a Crash
Chrysler Pacifica 2022–2025Chrysler Voyager 2022–2025
The side curtain airbags on certain 2022-2025 Chrysler Pacifica and Voyager vehicles may have improperly sealed seams, so they may not hold enough pressure during a crash.
May 7, 2025
Loose Engine Screws Can Leak Oil and Cause Fire
Audi Q5 2022–2024Audi Q5 Sportback 2022–2024
Some 2022-2024 Audi Q5 and Q5 Sportback Quattro vehicles may have cylinder head cover screws that were not tightened properly during assembly.
May 6, 2025
Moisture Can Short Transmission Pump Controller, Causing Fire
Hyundai Palisade 2025
A seal in the transmission's electric oil pump controller may not keep moisture out.
May 5, 2025
Passenger Air Bag May Not Deploy in a Crash
Porsche Taycan 2022–2023
An occupant classification sensor in the front passenger seat may wrongly deactivate the front passenger air bag.
May 2, 2025
Driver seat belt may loosen and fail to restrain in a crash
Mercedes-Benz C 300 2022–2025Mercedes-Benz AMG C43 2023–2024
The driver-side front seat belt cover may not be installed correctly on the seat belt tensioner.
April 28, 2025
Cooling Pump May Fail, Causing Loss of Drive Power
Isuzu NRR EV 2025
Some 2025 NRR EV trucks may have a mix of incompatible coolants in the cooling system.
April 24, 2025
Engine may fail unexpectedly, raising crash risk
Cadillac Escalade 2021–2024Cadillac Escalade ESV 2021–2024Chevrolet Silverado 1500 2021–2024+5 more models
Certain 2021 full-size Cadillac, Chevrolet and GMC SUVs and pickups equipped with the 6.2L V8 gas engine may have a connecting rod or crankshaft with a manufacturing defect.
April 23, 2025
Rearview camera may show a blank or distorted image
Ford Expedition 2015Ford F-450 2015Ford Redundant F-250 2015+3 more models
A loose or damaged connector on the rearview camera circuit board can cause the camera image to go blank or become distorted.
Missing Air Bag Warning Label Could Raise Injury Risk
Ford F-150 2025
Some 2025 Ford F-150 vehicles may have the air bag warning label missing from the dashboard.
Loose Battery Fasteners Can Cause Arcing and Fire Risk
Ford F-150 Lightning BEV 2022–2023
Some 2022 and 2023 Ford F-150 Lightning electric trucks may have fasteners securing the junction box bus bars inside the high-voltage battery pack that were not tightened securely.
April 18, 2025
Front control arm can detach and cause loss of steering
Ford Bronco 2025
The front upper control arm ball joint nut may be missing or improperly tightened, which can allow the upper control arm to separate from the knuckle assembly.
April 17, 2025
Certification label may show wrong weight and wheel data
Nissan Kicks 2025
Some vehicles may have a certification label printed with incorrect Gross Vehicle Weight Rating and Gross Axle Weight Rating values, which can lead to the vehicle being overloaded.
Stability warning light may fail to alert drivers to a system fault
Mercedes-Benz AMG G63 2025Mercedes-Benz G 550 2025Mercedes-Benz G 580 EV 2025
Certain 2025 Mercedes-Benz G-Class vehicles may display an incorrect warning light when the electronic stability program (ESP) system has failed.
Idler Gear Can Detach, Risking Engine Stall
Volvo VN 2022–2025Volvo VNL (4) 2025
The idler gear bracket fasteners on certain diesel engines may have been improperly tightened, which can allow the idler gear to come loose from the engine.
Tailgate Lights May Fail Due to Moisture, Raising Crash Risk
Acura MDX 2014–2020
Moisture can get into the tailgate lid light assembly and its wiring harness.
April 16, 2025
Damaged Front Brake Discs May Reduce Braking, Crash Risk
BMW X3 2025
Certain 2025 X3 30 xDrive vehicles may have had their front brake discs damaged during transport before installation.
April 15, 2025
Passenger Air Bag May Switch Off With Occupant Seated
Audi RS e-tron GT 2022–2023Audi e-tron GT 2022–2023
A wiring fault in the passenger occupant detection system can cause the front passenger air bag to deactivate even when the seat is occupied.