CarRecallWatchMay 15, 2019
Dragging Rear Brake May Cause Fire or Stop
IC Bus CE 2017IC Bus Cesb 2017
Certain 2017 IC CE transit buses are equipped with Bendix ADB 22X brake calipers, and the driver-side rear brakes may drag.
May 14, 2019
Warning lights may fail to show unbuckled seat belts or disabled passenger airbags
Mazda MAZDA3 2019
Certain vehicles have a programming error that can cause the passenger airbag off indicator light to turn off even when the passenger airbag is deactivated.
Loose Brake Caliper Bolts Can Reduce Braking Power
Fccc XC-L 2019Fccc XCM 2019Fccc XCR 2019+6 more models
Some 2019 heavy-duty trucks and chassis equipped with air disc brakes may have brake caliper mounting bolts that were not tightened enough at the factory.
Loose Brake Caliper Bolts Can Reduce Braking
Thomas Built Buses Saf-T-Liner C2 2019
Some 2019 Saf-T-Liner C2 school buses with air disc brakes may have brake caliper mounting bolts that were not tightened enough at the factory.
Insufficient air brake reservoir may reduce braking, raising crash risk
Freightliner M2 2005–2017Freightliner Cascadia 2013–2019Freightliner 108SD 2013–2018+17 more models
Some heavy trucks may have an air brake reservoir (tank) that is too small to meet federal brake standards.
Brake Pedal Pin Clip May Detach, Causing Brake Light Failure
Fccc MT 45 2012–2019Fccc MT 55 2012–2019
On certain 2012-2015 Freightliner Custom Chassis MT45 and MT55 vehicles, the clip that holds the brake pedal clevis pin can rub against or bend on the throttle pedal and may come loose.
Engine Block Heater Can Short Circuit and Cause Fire
International CV 2019
Certain 2019 trucks with Duramax 6.6 liter diesel engines and the optional engine block heater may have a problem with the block heater cord or the terminals connecting the cord to the block heater.
May 13, 2019
Rear Brakes May Release Late, Raising Crash Risk
Autocar Xpeditor 2019–2020
Certain 2019 and 2020 Autocar Xpeditor vehicles may have a rear axle air brake that releases later than it should.
Gap Beside Fold-Down Bunk Can Trap Occupants
Lance Camper Truck Camper (1172) 2019–2020Lance Camper Truck Camper (855S) 2019–2020
Certain 2019 and 2020 Lance truck campers (855S and 1172 models) may have a large gap between the fold-down bunk bed, when it is in the sleeping position, and the window near the sleeping area.
Brake lights may light up without the pedal pressed
Ford F-550 2017–2018
Certain 2017-2018 Ford F-550-based fire trucks equipped with Whelen brake lights may have brake lights that illuminate even when the brake pedal has not been pressed.
Brake Lights May Light Up Without Pedal Pressed
RAM 5500 2018
Some brake lights on this fire truck may illuminate even when the brake pedal has not been pressed, depending on how the vehicle's wiring is set up.
Brake Valve May Restrict Air Flow, Lengthening Stopping Distance
Spartan Gladiator 2018–2019Spartan K2 2019–2020Spartan K3 2018–2019+2 more models
Certain 2018-2019 emergency response chassis cabs and motor home chassis may have a brake relay valve with an air flow restriction.
Trailer brakes may not fully apply, raising crash risk
Trail King Tilt Trailer (Tkt) 2016–2019
Certain trailers have a missing air control line to the front anti-lock braking system (ABS) electronic control unit.
Fusion Shifter Bushing May Detach, Allowing Unexpected Rolling
Ford Fusion 2013–2016
Certain 2013-2016 Ford Fusion vehicles with 2.5 liter engines have a bushing that attaches the transmission shifter cable to the transmission.
Loose Wheel Lug Nuts Can Let Wheels Separate
Thunder Creek EV 2019Thunder Creek FST 2019Thunder Creek MTT 2019+1 more model
Certain trailers from this recall have wheel lug nuts that may loosen over time.
Incorrect slope placard could lead to unstable setup and injury
Altec Digger Derrick 2009–2019
A slope indicator placard on certain Digger Derrick vehicles may incorrectly state that the unit can be used without leveling on a 5 degree slope.
Shifter Bracket Can Loosen, Causing Unexpected Movement
Ford Ranger 2019
The fasteners that attach the transmission shifter cable bracket to the transmission can loosen.
May 10, 2019
Incorrect Weight Label Could Lead to Overloading and Crashes
Forest River Cherokee 2018–2019
Certain 2018-2019 Forest River Cherokee travel trailers may have a Federal Placard, the certification label that lists axle rating, cargo carrying capacity, and tire and wheel combination information, that contains incorrect figures.
Wiring Can Melt and Cause a Fire in Travel Trailers
Forest River R-Pod 2019–2020
Some travel trailers have the refrigerator's spark igniter wire connected to a 30-amp circuit breaker instead of the 15-amp circuit it should use.
May 9, 2019
Tailgate Can Unlatch and Open While Driving
RAM 1500 2013–2018RAM 2500 2013–2018RAM 3500 2013–2018
A plastic limiter tab in the power tailgate actuator may crack or fracture.
Loose battery ground can cut power steering or stall engine
Chrysler Pacifica 2017–2019
A loose battery ground connection in certain 2017-2019 Chrysler Pacifica minivans equipped with engine stop/start systems can cause an intermittent loss of power steering assist and/or a stall.
B-Pillar May Not Absorb Head Impact in a Crash
BMW X1 2016–2019
The upper interior B-pillars in these vehicles may not absorb enough energy if an occupant's head strikes them during a crash.
Driver's seat belt may not lock in a hard stop
Land Rover Range Rover 2016–2017Land Rover Range Rover Sport 2016–2017
The driver's seat belt emergency locking retractor may not lock at the correct force level.
Brake Delay May Increase Stopping Distance and Crash Risk
Jaguar I-Pace 2019–2020
If the electrical regenerative brake system fails, there can be a noticeable delay between when the driver presses the brake pedal and when the vehicle begins to slow down.
Knee airbag may not deploy properly in crash
BMW 230i 2019–2020BMW 430i 2019–2020BMW 440i 2019–2020+4 more models
The driver and passenger knee airbag assemblies in these BMW vehicles may have been improperly folded and assembled during manufacturing.
Brake lights may light up without the pedal pressed
Ford L9000 1994–1995Freightliner M2 2016–2017
Certain trucks equipped with Whelen brake lights may have brake lights that illuminate even when the brake pedal has not been pressed.
May 7, 2019
Wheel Can Separate From Axle, Raising Crash Risk
Hercules Enterprises Container Chassis 2018
The wheel end nut locking device on certain trailers may not have been properly installed.
May 3, 2019
Brake lights may light up without the brake pedal pressed
Ford E-350 2017–2018Ford E-450 2017–2018Ford F-450 2017–2018+2 more models
Some 2017-2018 ambulances built on Ford E-350, E-450, F-450, and F-550 chassis, and GMC G3500 chassis, were equipped with Whelen brake lights that, depending on how the vehicle is wired, may illuminate even when the brake pedal has not been pressed.
Roof Hatch Glass May Shatter, Dropping Fragments on Passengers
MCI J4500 2018–2019MCI D4505 2019MCI J3500 2019
Certain Motor Coach Industries buses have a tempered glass roof hatch that can shatter when exposed to temperature changes and vibration.
Rear Clearance Lamp May Be Misplaced, Reducing Visibility
Supreme Platform 2018–2019
The rear clearance lamp on certain vehicles may be mounted in the wrong position, where it blocks part of the light pattern the lamp is required to project.