CarRecallWatchOctober 18, 2022
Steering Tie Rod Can Separate, Causing Loss of Steering
Kenworth T370 2023Kenworth T480 2023Kenworth T800B 2023+8 more models
The tie rod clamps on these trucks may have been improperly heat-treated.
October 17, 2022
Steering Tie Rods May Separate, Causing Loss of Steering
Spartan Fire FC-94 2021–2023Spartan Fire Gladiator 2021–2023Spartan Fire Metrostar 2021–2023+2 more models
Certain emergency vehicles built on these chassis have tie rod clamps that may have been improperly heat-treated.
Digital Display May Freeze, Hiding Speed and Warning Lights
Kenworth T680 2022–2023Kenworth T880 2022–2023Kenworth W990 2022–2023+5 more models
Certain 2022 Kenworth and Peterbilt trucks may have an instrument cluster digital display that freezes and stops showing critical safety information, such as vehicle speed and warning lights.
Emergency Lights May Fail, Reducing Visibility
An electrical module in some emergency vehicles may have an extra resistor installed incorrectly on its circuit board.
October 14, 2022
Cooktop Flame Can Invert, Raising Injury and Fire Risk
Jayco Travel Trailer JAY Feather 2021–2022Jayco Travel Trailer JAY Flight 2021–2022Jayco Travel Trailer JAY Flight SLX 2021–2022
Certain 2021-2022 travel trailers may have a cooktop flame that inverts when the stove and furnace are operated at the same time.
Cooktop Flame May Invert, Raising Fire and Injury Risk
Starcraft RV TT Autumn Ridge Outfitter 2019, 2021
Certain Autumn Ridge Outfitter travel trailers may have a cooktop flame that inverts when the stove and furnace are operated at the same time.
Cooktop Flame Can Invert, Raising Injury and Fire Risk
Highland Ridge TT Olympia 2021–2022Highland Ridge TT Olympia Sport 2021–2022Highland Ridge TT Open Range 2021–2022+2 more models
Certain travel trailers have a defect in which the cooktop flame may invert when the stove and furnace are operated at the same time.
Parking Brake May Engage Unexpectedly, Raising Crash Risk
Spartan K4 2023
On certain 2023 Spartan RV Chassis K4 motorhomes, the pneumatic parking brake interlock valve may have been installed incorrectly.
Trailer Axle Weld Can Crack and Separate, Raising Crash Risk
HD Trailer NON CDL Goosenecks 2022
Certain 2022 non-CDL gooseneck trailers fitted with Besser Pro 7000 lb tubular straight axles may have a weld joining the spindle to the main axle that was placed improperly.
October 13, 2022
Front Seat Belts May Fail to Tighten in a Crash
Jeep Gladiator 2022Jeep Wrangler 2021RAM 1500 2022
Some front seat belt retractors may have an improperly welded micro gas generator.
Fuel pump may fail and stall the engine, raising crash risk
Jeep Wrangler 2020–2022RAM 1500 2020–2022Jeep Gladiator 2021–2022
Certain 2020-2022 Jeep Wrangler and Ram 1500 vehicles and 2021-2022 Jeep Gladiator vehicles equipped with the 3.0L diesel engine may have a high pressure fuel pump (HPFP) that can fail.
Fuse may overheat and cause loss of drive power
Jeep Wrangler 2022–2023
The high voltage battery pack in these plug-in hybrid vehicles was built with incorrect fasteners securing the 200-amp fuse.
Fuel Cap May Not Seal, Risking Leaks and Fire
Jayco Fifth Wheel Seismic 2023
The fuel cap on the cargo fuel tank may not fit properly onto the filler fuel neck.
Wiring Can Chafe Axle and Cause Fire Risk
Storyteller Overland Mode LT 2022–2023
Certain 2022-2023 Storyteller Overland Mode LT motorhomes may have wiring connecting the secondary alternator to the auxiliary power system routed improperly.
Battery Seal May Leak, Causing Sudden Power Loss
GMC Hummer EV Pickup 2022–2023Brightdrop EV600 2022
The high-voltage traction battery pack in these electric vehicles may not be properly sealed, so water can get into the pack.
Rearview Display May Fail After Restart, Raising Crash Risk
Nissan Frontier 2022Nissan Redundant Rogue 2022Nissan Rogue 2021+2 more models
Certain Nissan pickups and SUVs may have an infotainment system that repeatedly reboots each time the vehicle is started.
October 12, 2022
Roof panel joints may separate in a crash
Thomas Built Buses Saf-T-Liner EFX 2011–2023Thomas Built Buses Saf-T-Liner HDX 2011–2023
Certain Thomas Built Saf-T-Liner EFX and HDX school buses have an exterior roof panel that was made with insufficient joint strength.
Bus Entrance Handrail Too Thin, Risk of Slips and Falls
Blue Bird ALL American Transit Bus 2023Blue Bird Vision Transit Bus 2023
The entrance door handrail on these buses has a diameter smaller than required by federal accessibility standards, which call for at least 1.25 inches.
Rearview camera image may be delayed or blank, raising crash risk
Volkswagen ID.4 2022
Certain 2022 Volkswagen ID.4 vehicles may have a rearview camera image that is delayed or deactivated.
October 11, 2022
Rear Brake Hose May Rupture, Causing Loss of Braking
RAM 4500 2019–2020RAM 5500 2019–2020
The inside diameter of the rear brake hoses on these trucks may be too small.
Transmission Fault Can Cause Sudden Loss of Drive Power
Kia K5 2021–2023Kia Sorento 2021–2022
A transmission oil pump malfunction can impair the vehicle's fail-safe limited-mobility drive mode, which may result in a complete loss of drive power.
Hopper lift may keep rising after being turned off
Schwarze A9SE Monsoon 2021–2022
Certain 2021 and 2022 Schwarze A9SE Monsoon single-engine street sweepers can have a hydraulic problem in the hopper lift system.
October 10, 2022
Air Line May Rub Through, Causing Sweeper Power Loss
Elgin Sweeper Crosswind 1 (Pb 220) 2020–2023
On certain 2020-2023 Elgin Crosswind 1 sweepers built on Peterbilt 220 chassis, the stainless steel braided supply line for the engine air compressor can rub against the oil suction tube that runs from the Variable Power Divider sump to the hydrostatic pump.
Rear Reflective Tape Hidden by Liftgate, Crash Risk
Wabash National Rfalhsa 2020–2023
On certain 2020-2023 Wabash RFALHSA trailers, the liftgate covers the rear conspicuity tape mounted at deck height.
October 9, 2022
Living Room Slide Window May Lack Emergency Exit
Kzrv Durango 2023
Certain travel trailers may be missing the emergency exit window in the living room slide-out.
October 8, 2022
Awning seam may separate and awning can drop unexpectedly
Riverside Intrepid 2023Riverside Retro 2023Riverside Xplorer 2023
A welded seam on the fabric of the electric retractable awning may separate.
October 7, 2022
Rearview camera image can be partly blocked, raising crash risk
BMW 330e 2023
After the vehicle is shifted into reverse, the rearview camera software may obstruct part of the rear camera image.
Brake pedal may hit dash, causing brake failure
Newmar Dutch Star 2023
On certain 2023 motorhomes, the adjustable brake pedal can come into contact with the dash panel.
Incorrect rear tire size label could lead to wrong tire fitted
Newmar Super Star 2020–2023
The Federal Certification label on certain 2020-2023 Newmar Super Star motorhomes may show the wrong tire size for the rear tires.
Bunk Brackets May Fail, Risking a Fall
Forest River Avenger 2023
Certain travel trailers have rear bunkroom flip-up bunks whose supporting brackets may not be installed properly.