CarRecallWatchSeptember 28, 2017
Engine wear can lead to engine failure and crash risk
Hino NE8J 2011–2012Hino NJ8J 2011–2012Hino NV8J 2011–2012
Certain diesel engines in these trucks may have wrist pin bushings in the connecting rods that can shift.
September 27, 2017
Counterweight Tube Can Detach While Driving, Raising Crash Risk
Wabash Converter Dolly 2012–2013
On certain converter dollies, the fasteners that attach the counterweight tube to the dolly body can wear or loosen over time.
Caliper Bolts May Loosen, Causing Loss of Braking
Certain trailers were built with brake caliper bolts that may not have been properly torqued at the factory.
September 26, 2017
Trailer Brakes May Be Installed Wrong, Raising Crash Risk
Trail King Flatbed Trailer 2013–2018
Certain flatbed trailers from 2013 through 2018 may have had their axles installed incorrectly.
Incorrect tire label may lead to overloading or wrong tire pressure
RAM Promaster City 2015–2017
The tire placard on certain 2015-2017 RAM ProMaster City vans lists wrong information, such as the vehicle's weight capacity, number of occupants, tire pressure, or a "None" entry for the spare tire size when a full-size spare is installed.
Trailer side markers mounted too high, hard to see
C&M Cargo Trailer 2015–2016
Certain trailers over 80 inches wide were built with side marker lamps mounted higher than 60 inches off the ground.
September 25, 2017
Loose Steering Tie Rod Can Cause Loss of Steering Control
Ford F-650 SD 2015Ford F-750 SD 2015
A castellated nut on the steer axle may not have been properly tightened at the factory, allowing the tie rod to loosen over time.
Electrical switch may fail and increase fire risk
Keystone Raptor 2008–2009
Certain RVs have an IOTA ITS-50R transfer switch that may fail when exposed to high electrical loads in higher ambient temperatures.
Missing Roof Rivets Can Weaken Rollover Protection
Ford F-150 2018
Some 2018 F-150 Raptor Super Cab trucks without a moonroof may be missing rivets where the structural roof braces attach to the roof rail.
Passenger Seat Belt May Not Hold in a Crash
Ford F-150 2017Ford F-250 SD 2017Ford F-350 SD 2017+2 more models
Certain 2017 Ford F-150, F-250, F-350, F-450, and F-550 trucks with manually adjusted front passenger seats may have a seat belt anchor that is not adequately welded to the seat cushion frame.
September 22, 2017
Propane Line Damage Can Cause Fire
Jayco Greyhawk 2016–2017
Certain Greyhawk motorhomes may have a liquid propane (LP) line that is damaged.
Rear reflectors may be hard to see, raising crash risk
BMW F800 GT 2014–2016BMW F800 R 2015–2016
Certain 2014-2016 BMW F800 GT and 2015-2016 F800 R motorcycles have rear side reflex reflectors that may not be properly visible in some traffic conditions, so the bike does not fully meet federal lighting and reflective device requirements.
Loose Driveshaft Can Puncture Fuel Tank, Causing Fire Risk
Mercedes-Benz Sprinter 2500 2016Mercedes-Benz Sprinter 3500 2016
Some vans were built without a driveshaft catch strap.
Loose Steering Tie Rod Can Cause Loss of Steering
Kenworth K170 2016Kenworth T170 2016Kenworth T270 2016+24 more models
A castellated nut on the steer axle may not be properly torqued, allowing the tie rod to loosen on certain 2016 Kenworth trucks equipped with specific Spicer steer axles.
Power Steering May Cut Out, Raising Crash Risk
Mercedes-Benz Metris 2015–2017
Certain 2015-2017 Mercedes-Benz Metris vans have electric power steering control units with improperly welded contact pins.
Roof Panels May Separate in a Crash, Raising Injury Risk
Some school buses were assembled with inconsistent adhesive applied to the roof panels.
September 21, 2017
Bus Seats May Work Loose, Raising Injury Risk in Crashes
Glaval Bus Apollo 2017–2018Glaval Bus Concorde II 2017–2018Glaval Bus Entourage 2017–2018+6 more models
Certain buses have seats mounted with washers that can crack and dislodge, so the seat may not be securely attached to the floor.
Engine May Stall From Crankshaft Failure, Raising Crash and Fire Risk
Kia Sorento 2017
The engine crankshaft may have been improperly heat treated, so it can fail.
Seats May Lack Bracket, Raising Crash Injury Risk
Thomas Built Buses Saf-T-Liner C2 2014–2018Thomas Built Buses Saf-T-Liner HDX 2014–2018
Some school buses have seats that may be missing a reinforcement bracket.
Battery Cable May Chafe and Cause a Fire
Western Star 4700 2013–2018
Some trucks have a battery cable that may contact the all-wheel-drive axle yoke.
Bus Seats May Lack a Bracket, Raising Crash Injury Risk
Thomas Built Buses Saf-T-Liner C2 2014–2018Thomas Built Buses Saf-T-Liner HDX 2014–2018
Some Thomas Built Buses Saf-T-Liner HDX and C2 transit buses from model years 2014 through 2018 may be missing a reinforcement bracket on seats that have 3-point seat belts.
September 20, 2017
Loose Steering Tie Rod Can Cause Loss of Steering
IC Bus HC 2016International 9900I 2016International Durastar 2016+5 more models
Certain 2016 commercial trucks and buses with specific Spicer D or E series steer axles may have a castellated nut that was not properly torqued.
Fuel Pump Flange May Crack and Leak Fuel, Causing Fire Risk
Porsche Cayenne S 2003–2006Porsche Cayenne Turbo 2003–2006Porsche Cayenne 2004–2006
The fuel pump flange on certain gasoline-powered Porsche Cayenne vehicles may crack, allowing fuel to leak from the fuel system.
Front coil springs can fracture and puncture a tire
Some 2018 vehicles may have front coil springs that were improperly manufactured.
Engine bearings can wear and cause stalling
Hyundai Santa FE 2017
Some crankshaft assemblies may have been made with surface irregularities on the crankshaft pin.
Brake hose can rub tire, causing brake fluid leak
IC Bus Cesb 2018–2019
On certain school buses, the hydraulic brake hose on the front (steer) axle may be routed improperly, so it can contact the tire.
Loose Steering Tie Rod Can Cause Loss of Steering
IC Bus Cesb 2016
Certain 2016 school buses may have a castellated nut on the steer axle that was not properly torqued.
Fuel pump gear can slip, causing sudden engine stall
Rosenbauer Commander 2017
This recall covers one 2017 emergency vehicle with a Cummins X15 diesel engine.
Driver seat belt buckle may stick and fail to latch
Hometown Trolley Mainstreet 2016–2017Hometown Trolley Streetcar 2016–2017Hometown Trolley Villager 2016–2017
On certain 2016-2017 Hometown Trolley buses equipped with Recaro commercial bus driver seats, the seat belt buckle can become stuck in the locked position.
Fuel Filter Flange May Crack and Leak, Raising Fire Risk
Volkswagen Touareg 2004–2007
The fuel filter flange on certain gasoline-powered vehicles may crack, allowing fuel to leak.