CarRecallWatchThe 2020 Autocar Xpeditor has 22 safety recalls on file with NHTSA.
2020 Autocar Xpeditor recalls
Insufficient Brake Air Tank Volume Can Lengthen Stopping Distance
Certain Autocar Xpeditor and Xspotter trucks from model years 2015 through 2018 have air tanks that do not hold enough air for the brake system.
Parking Brake Warning Light May Show Falsely, Raising Crash Risk
Certain Autocar Xpeditor (ACX) and Legend (DC) trucks may have a parking brake warning light that illuminates incorrectly during an air loss event.
Park brake warning light may illuminate incorrectly
The park brake warning light may turn on incorrectly during an air loss event.
Water Can Short Fuse Box, Risking Sudden Stalls
The external fuse box on these trucks can short circuit when water gets into it.
Sun Visor May Block Roof Clearance Lights, Raising Crash Risk
The external sun visor on certain Xpeditor trucks may obstruct the roof-mounted clearance lights.
Parking Brake May Release Unexpectedly, Allowing Rollaway
A worn parking brake control valve can leak air into the vent line.
Fuse Box Can Short Out and Stall the Truck
The external fuse box on these trucks can short circuit when water gets into it.
Hazard lights may not work with ignition off
The hazard warning lights on certain vehicles may not work when the ignition is off.
Fuel tubes may crack and leak, creating fire risk
Fuel tubes between the fuel rail and the injectors for cylinders four, five, and six may fatigue and crack, which can cause a high pressure fuel leak.
Engine May Stall While PTO Is Engaged, Risking Rollback
This recall covers certain Autocar Xpeditor trucks, including 2019 and 2020 models, that have an aftermarket power take off (PTO) installed.
Hazard lights may not work with ignition off
Certain Autocar Xpeditor trucks from model years 2019 through 2022 have a software problem that stops the hazard warning lights from working when the ignition is turned off.
Warning lights may not show during display restart
The instrument display in these trucks may restart while the vehicle is running.
Turbo Heat Shield May Detach and Become a Road Hazard
A turbocharger heat shield on certain vehicles may fail and detach from the vehicle while driving.
Engine May Stall and Not Restart Without Warning
Some Autocar Xpeditor trucks from model years 2018 through 2021 may have a seat belt harness routed too close to the seat mechanism.
Engine May Stall and Not Restart, Raising Crash Risk
The engine ground cable on certain vehicles with X12N engines is too short and may fail.
Loose Suspension Bolts Could Detach and Cause a Crash
Some Autocar Legend and Xpeditor trucks from model years 2020 and 2021 may have transverse torque rod mounting bolts that were not properly tightened at the factory.
Parking Brake May Apply Unexpectedly, Raising Crash Risk
Certain 2018-2021 Autocar Xpeditor trucks with a right-hand drive cab, which have the park brake valve (button) located to the right of the steering wheel, may have the parking brake synchronization valve plumbing improperly assembled.
Traction control may malfunction without warning, raising crash risk
The traction control electronic control unit (ECU) on certain vehicles may not be programmed correctly, so it can malfunction without warning.
Ignition Relay May Fail, Stalling Engine Unexpectedly
The ignition relay in these vehicles may fail without warning, causing the vehicle to stall.
Loose Power Steering Pump Bolts Can Cause Sudden Loss of Steering
The mounting bolts that secure the power steering pump may loosen over time, which can allow the pump to disconnect from the vehicle.
Rear Brakes May Release Late, Raising Crash Risk
Certain 2019 and 2020 Autocar Xpeditor vehicles may have a rear axle air brake that releases later than it should.
Brake Pin Retainer May Be Missing, Longer Stopping Distance
Some Autocar Xpeditor trucks from 2019 and 2020 may have been built without the retainer that holds the brake chamber clevis pin in place.
2020 Autocar Xpeditor questions
Does the 2020 Autocar Xpeditor have any recalls?
Yes. NHTSA lists 22 safety recalls for the 2020 Autocar Xpeditor: Insufficient Brake Air Tank Volume Can Lengthen Stopping Distance; Parking Brake Warning Light May Show Falsely, Raising Crash Risk; Park brake warning light may illuminate incorrectly; Water Can Short Fuse Box, Risking Sudden Stalls; Sun Visor May Block Roof Clearance Lights, Raising Crash Risk. Recall repairs are normally free at an authorized dealer.
How do I check if a recall on my 2020 Autocar Xpeditor has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.