CarRecallWatchThe 2015 Autocar Xpeditor has 19 safety recalls on file with NHTSA.
2015 Autocar Xpeditor recalls
Insufficient Brake Air Tank Volume Can Lengthen Stopping Distance
Certain Autocar Xpeditor and Xspotter trucks from model years 2015 through 2018 have air tanks that do not hold enough air for the brake system.
Parking Brake May Release Unexpectedly, Allowing Rollaway
A worn parking brake control valve can leak air into the vent line.
Frame Cross-Member Can Loosen and Detach, Raising Crash Risk
On certain Autocar Xpeditor trucks, the first cross-member behind the engine may have mounting brackets that fail early.
Traction control may malfunction without warning, raising crash risk
The traction control electronic control unit (ECU) on certain vehicles may not be programmed correctly, so it can malfunction without warning.
Ignition Relay May Fail, Stalling Engine Unexpectedly
The ignition relay in these vehicles may fail without warning, causing the vehicle to stall.
Drive shaft support cross member may fail, risking crash
The drive shaft support cross member in certain Xpeditor trucks may fail.
Parked Truck Can Roll Away, Crash Risk
Certain Autocar Xpeditor trucks were built with undersized parking brake chambers.
Wiring May Overheat and Cause a Fire
The methane detection system's wiring may not be properly protected against excess electrical current, and the wiring harness may be routed improperly.
Loose Tie Rod Could Cause Loss of Steering
A castellated nut on the steer axle may not be properly tightened, allowing the tie rod to loosen.
Brakes May Engage Unexpectedly, Raising Crash Risk
Certain 2013-2016 Autocar Xpeditor trucks equipped with auxiliary axles and 36/36 rear brake chambers can experience excessive vibration from over-braking.
Loose Drive Unit Bolts Could Detach, Causing Crashes
Some Autocar Xpeditor trucks from the 2012 through 2016 model years, built between September 2011 and October 2015, may have hybrid power drive unit cradle mounting bolts that were not properly tightened.
Engine May Stall Due to Fuse Box Vibration
Vibration in the fuse box can cause the ignition relay to open, which may shut off the engine while the vehicle is being driven.
Steering Parts Can Separate, Causing Loss of Steering
Some steering linkage castle nuts may not have been tightened properly at the factory.
Brake pedal can detach, raising crash risk
On certain dual-drive, right-hand-stand-up cab trucks built between August 15, 2012 and January 5, 2016, the locking cotter pin on the brake pedal mounting bracket may not be fully engaged.
Brakes May Stick and Drag, Risking Loss of Control
On certain Xpeditor trucks built between January 2014 and August 2015, the right-side brake plunger in dual-drive, right-hand stand configurations may stick, causing the brakes to drag.
Defrost Actuator May Overheat and Cause a Fire
Some Autocar Xpeditor trucks have heating, ventilation and air conditioning (HVAC) units whose defrost mode door actuators may overheat.
Parking Brake May Engage Unexpectedly While Driving
The parking brake control valve (synchronization valve) on certain trucks can cause the parking brake to engage if the driver tries to release it without first firmly pressing the service brake.
Oil Leak Near Hot Parts Can Cause Engine Fire
Excessive crankcase pressure can cause a vent tube elbow to detach from the crankcase breather.
Fuel filter can separate, causing sudden engine stall
The fuel filter on certain trucks may have a shell that can separate from its nut plate.
2015 Autocar Xpeditor questions
Does the 2015 Autocar Xpeditor have any recalls?
Yes. NHTSA lists 19 safety recalls for the 2015 Autocar Xpeditor: Insufficient Brake Air Tank Volume Can Lengthen Stopping Distance; Parking Brake May Release Unexpectedly, Allowing Rollaway; Frame Cross-Member Can Loosen and Detach, Raising Crash Risk; Traction control may malfunction without warning, raising crash risk; Ignition Relay May Fail, Stalling Engine Unexpectedly. Recall repairs are normally free at an authorized dealer.
How do I check if a recall on my 2015 Autocar Xpeditor has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.