CarRecallWatchMay 8, 2020
School Buses May Roll on Inclines Due to Parking Brake
Blue Bird ALL American School Bus 2020–2021Blue Bird Vision School Bus 2020–2021
The foot pedal parking brake on certain 2020-2021 Blue Bird Vision and All American school buses may have been improperly assembled.
Parking Brake May Fail to Hold Bus on Incline
Blue Bird Vision Transit Bus 2020–2021Blue Bird ALL American Transit Bus 2021
The foot pedal parking brake assembly on certain buses may have been improperly assembled.
Roof Panel Can Separate While Driving, Raising Crash Risk
Ford Transit Connect 2014–2017
The panoramic fixed-glass roof may have an improper bond to the vehicle body.
Loose Tow-Truck PTO Can Leak Fluid and Lock Rear Wheels
International CV 2019–2020International Motors Chevy Silverado Medium Duty 2019–2020
On certain 2019-2020 International CV and Chevrolet Silverado medium-duty tow vehicles with Allison 2700 series transmissions and Chelsea Power Take Offs, the PTO was installed incorrectly.
Pre-Collision Assist May Not Be Enabled, Raising Crash Risk
Ford Expedition 2020Lincoln Navigator 2020
On certain 2020 Ford Expedition and Lincoln Navigator vehicles equipped with the camera-only Pre-Collision Assist system, incorrect coding of interfacing modules means the Pre-Collision Assist feature is not turned on, and the driver cannot access the menu needed to enable it.
Warning chime too short; car can roll if left out of Park
Ford Mustang 2019–2020Ford Expedition 2019
The instrument cluster warning that tells the driver the transmission is not in Park, along with its chime, lasts for less time than intended.
May 7, 2020
Corroded Connector Can Cause Loss of Power Steering
Chevrolet Caprice Police Pursuit 2015–2016Chevrolet Cheverolet SS 2015–2016
Corrosion in the connector between the electric power steering module and the torque sensor can cause a loss of electric power steering assist.
Engine Rod Bushing Can Fail, Causing Sudden Shutdown
International LT 2018–2020International RH 2019–2020
The wrist pin bushing in the engine connecting rod may fail on certain 2018-2020 International LT and 2019-2020 International RH trucks.
Traction control may malfunction without warning, raising crash risk
Autocar Xpeditor 2015–2020
The traction control electronic control unit (ECU) on certain vehicles may not be programmed correctly, so it can malfunction without warning.
May 5, 2020
Fuel Line Can Chafe and Leak, Creating Fire Risk
Blue Bird Vision 2018–2019Blue Bird Vision School Bus 2020–2021Blue Bird Vision Transit Bus 2020–2021
On certain Blue Bird Vision buses with a Ford 6.8L gasoline engine and a right-hand mounted parking brake lever, the parking brake cable was routed improperly.
Seat Belt May Not Properly Secure Occupant in a Crash
Ford Transit 2019–2020RAM Promaster 2019
Certain vans equipped with Freedman GO-ES foldaway seats may have a front seat belt retractor that was not set correctly.
Connector can unplug, causing sudden loss of drive power and steering
Freightliner Business Class M2 2019
A connector in the wire harness of certain electric drivetrains may become unplugged.
Small rear emergency exit label may slow escape
Thomas Built Buses Saf-T-Liner HDX 2010–2020
The instruction label for the rear emergency exit window on certain Saf-T-Liner HDX school buses may have lettering that is too small.
May 4, 2020
Driver Airbag Could Detach From Steering Wheel
The driver-side frontal airbag's mounting bolts may not have been tightened enough during assembly, so the airbag could come loose from the steering wheel.
May 1, 2020
Front brake pads may corrode and lose friction material
Aprilia RSV4 RR 2017–2020Aprilia Tuono RF 2017–2020Aprilia Tuono RR 2017–2020+1 more model
Certain Aprilia RSV4 and Tuono motorcycles from model years 2017 and 2018 may have front brake pads that corrode.
Water Can Enter Foot Wells, Causing Stalls or a Blank Dash
Water can get in through the wheel well area and into the front footwells of this vehicle.
Rear Door Child Lock Label May Show Wrong Status
Mercedes-Benz G 550 2019–2020Mercedes-Benz G63 2019–2020
Certain 2019-2020 Mercedes-Benz G 550 and G63 vehicles have an embossed child safety lock symbol on the rear doors that may show the wrong lock status.
April 30, 2020
Battery ground cable may break, blocking engine restart
Hino NE8A 2020–2021Hino NE8C 2020–2021Hino NE8G 2020–2021+7 more models
A ground cable connecting the negative battery terminal to the vehicle frame may be too short and may break.
April 29, 2020
CNG Tank Pressure Relief Valve May Fail in Heat, Risking Rupture
Gillig LOW Floor 2018–2020
Certain 2018-2020 Gillig Low Floor transit buses powered by compressed natural gas (CNG) may have a thermally activated pressure relief device (PRD) that does not vent the fuel system when exposed to heat.
Aerial Lift May Tip if Used on Uneven Ground
Terex TL80 2019–2020Terex TL80/112 2019–2020
The slope indicator and decals on certain 2019-2020 Terex TL80 and TL80/112 aerial devices incorrectly state that the chassis can be up to 5 degrees out of level during aerial device use.
Loose Steering Gear Fasteners Can Cause Loss of Control
Volvo VNL 2020–2021Volvo VNR 2020–2021
Some 2020-2021 Volvo heavy-duty trucks may have steering gear fasteners that were not properly tightened during assembly.
Seat Belts May Not Extend, Making Them Unusable in a Crash
MCI D4500 2015–2020MCI D4505 2015–2020MCI J4500 2016–2020+3 more models
Certain Motor Coach Industries buses have seat belts that may not extend from their retracted position.
Front Airbag Inflators May Fail to Deploy Properly
BMW 530e 2017–2018BMW 530i 2017BMW 540i 2017
Certain BMW 5 Series and 540i vehicles may have front head airbag inflators that were exposed to excessive humidity.
April 28, 2020
Front brake pads may corrode and detach, longer stopping distance
Triumph Street Triple RS 2018–2020Triumph Tiger 1200 XCA 2018–2020Triumph Tiger 1200 XCX 2018–2020+8 more models
Front brake pads on certain motorcycles may corrode, which can cause the pad friction material to separate from its metal backing plate.
Seat Belt May Not Properly Secure Passengers
Startrans PS2 2020
Certain transit buses have front seat belt retractors that may not have been set up correctly during manufacturing.
Propane Hose Can Leak and Cause Fire or Explosion
Jayco Travel Trailer JAY Flight SLX 2020
A propane supply hose connection to the refrigerator may be improperly tightened, which can allow propane to leak from the trailer's LPG system.
April 27, 2020
Cracked Air Brake Hoses Can Cause Longer Stopping Distances
MCI J4500 2014–2019MCI J3500 2018–2019
Certain Motor Coach Industries J4500 and J3500 motor coaches from model years 2014 through 2019 may have brake hoses that crack or otherwise fail, causing an air leak.
School Bus Parking Brake May Fail to Hold on Slopes
Blue Bird Vision 2006–2019Blue Bird ALL American 2007–2013Blue Bird Vision School Bus 2020–2021+1 more model
The floor-mounted parking brake on certain Blue Bird Vision and All American school buses may not apply enough force to hold the vehicle still on an incline when it is loaded to its maximum weight.
Parking Brake May Fail to Hold Bus on Slopes
Blue Bird Vision 2009–2019
The floor-mounted parking brake on these transit buses may not apply enough force to hold the vehicle still on an incline when it is loaded to its maximum weight.
April 23, 2020
Fuel Tank Corrosion Can Cause Leaks and Fire Risk
Mclaren 720S 2016–2020Mclaren 570 GT 2017–2019Mclaren GT 2020+1 more model
The foam pad under the fuel tank can trap moisture, which may corrode the tank and cause a fuel leak.