CarRecallWatchThe 2018 Volvo VNL has 5 safety recalls on file with NHTSA.
Owners have filed 8 complaints with NHTSA, including 1 crash, 1 injury.
The most-reported problem area is Power Train (3 reports).
2018 Volvo VNL recalls
Label Overstates Rear Axle Capacity; Hubs May Fail
Certain 2018-2021 Volvo VNL and VNR trucks have a Federal Certification Label that lists a rear drive axle Gross Axle Weight Rating (GAWR) higher than the rating of the wheel hubs.
Blown Fuse Can Stop Transmission From Shifting
A fuse in the transmission circuit of certain Volvo trucks may blow.
Sleeper Window Can Detach and Fall From Truck
The sleeper bunk window on certain trucks may detach and fall from the vehicle while it is being driven.
Clutch Part May Fail, Causing Unintended Vehicle Movement
Certain trucks with an automated manual transmission have an internal clutch assembly component that may fail.
Fuel Line Can Burst and Engine Can Stall Without Warning
A restricted screen in the fuel pump cooling circuit can cause the fuel line to burst, especially during extended downhill driving.
Most common 2018 Volvo VNL problems
Problem areas named in the 8 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Power Train | 3 |
| Vehicle Speed Control | 2 |
| Steering | 2 |
| Air Bags | 1 |
| Service Brakes | 1 |
| Electrical System | 1 |
| Engine | 1 |
| Fuel System, Gasoline | 1 |
What owners report
The contact owns a Volvo 2018 VNL64 Commercial vehicle. The contact stated that the vehicle would shut down while driving at various speeds. There was no further information provided. The vehicle was towed to the dealer, where the high pressure fuel pump filter, the differential pressure sensor, the rear wire harness were replaced. Additionally, the contact stated that the vehicle was experiencing transmission failures and would fail to respond intermittently while reversing. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 537,850.
The contact owns a 2018 Volvo VNL Truck. The contact stated while driving at various speeds, the vehicle was lunging forward and failed to properly respond while depressing the accelerator pedal. There was no additional information provided. The vehicle was taken to the dealer, where it was diagnosed that the transmission clutch and transmission needed to be replaced. The vehicle was repaired; however, the power train warning light illuminated a week later. The vehicle was taken back to the dealer. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 600,000.
The contact owns a 2018 Volvo VNL. The contact stated that while approaching a stop, the clutch failed to disengage. The contact also stated that after decelerating, he depressed the accelerator pedal and the vehicle rolled back. The contact stated that the check warning light illuminated, indicating to check the transmission at the next stop. The vehicle was taken to the dealer where it was diagnosed and produced code: DTC-P107538 (Throttle Actuator Control Module) however, the contact was informed by the dealer that the clutch needed to fail 5 more times before the vehicle would be repaired. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage
2019 COMPLAINED TO THE DEALER ABOUT UNEVEN WEARING OF THE FRONT TIRES THEY CHECKED ALIGNMENT THEN SAME COMPLAINT IN MARCH 2020 NO DEFECTS FIND THEN IN JULY 02 2020 I WAS UNABLE TO DRIVE BECAUSE OF VIBRATION , AFTER INSPECTION THEY FOUND PLASTIC BUSHINGS FOR BOTH KINGPINS WORN OUT AND REPLACED AS WHOLE SETS. MY COMPLAINT IS ABOUT PREMATURE FAILURE COMPONENTS AT 300000 MILES DUE TO USE OF PLASTIC BUSHINGS BY MANUFACTURER. TRUCK WAS USED ON HIGHWAYS NOT AS A VOCATIONAL TRUCK
ENGINE WORKING NOT PROPERLY AND SHAKING!!!ITS HAPPENED IN 2019 !!! NOW THE SAME PROBLEM AGAIN!!!
2018 Volvo VNL questions
Does the 2018 Volvo VNL have any recalls?
Yes. NHTSA lists 5 safety recalls for the 2018 Volvo VNL: Label Overstates Rear Axle Capacity; Hubs May Fail; Blown Fuse Can Stop Transmission From Shifting; Sleeper Window Can Detach and Fall From Truck; Clutch Part May Fail, Causing Unintended Vehicle Movement; Fuel Line Can Burst and Engine Can Stall Without Warning. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2018 Volvo VNL?
Based on 8 owner complaints filed with NHTSA, the most-reported problem areas are Power Train (3), Vehicle Speed Control (2), Steering (2).
How do I check if a recall on my 2018 Volvo VNL has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.