CarRecallWatchThe 2018 Volvo XC60 has 5 safety recalls on file with NHTSA.
Owners have filed 36 complaints with NHTSA, including 4 crashes, 4 injuries.
The most-reported problem area is Electrical System (11 reports).
2018 Volvo XC60 recalls
Loose Front Seat Bolts Could Fail to Restrain Occupants
Certain Volvo XC60 vehicles from model years 2018, 2025 and 2026 may have had their front seat bolts improperly tightened at the factory, so some bolts may be loose.
Loose Front Wiper Nuts Can Impair Windshield Visibility
Certain front windshield wiper arm nuts may not have been tightened enough at the factory.
Front seats may lack nuts, raising crash injury risk
Some front seat rails may be missing rear flange nuts from assembly.
Tailgate Lift Arms May Separate in Cold Weather
In certain cold-temperature conditions, the tailgate lifting arms can freeze, which may cause the arms to separate from the vehicle.
Software error may block GPS location for emergency crews
A software error in the Vehicle Connectivity Module (VCM) can cause the telematics and driver support systems to malfunction.
Most common 2018 Volvo XC60 problems
Problem areas named in the 36 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Electrical System | 11 |
| Service Brakes | 7 |
| Air Bags | 5 |
| Unknown Or Other | 4 |
| Structure | 4 |
| Vehicle Speed Control | 3 |
| Engine | 3 |
| Lane Departure | 3 |
| Electronic Stability Control (Esc) | 2 |
| Steering | 2 |
What owners report
The contact owns a 2018 Volvo XC60. The contact stated that after starting the vehicle, while driving at a slow speed, the brake pedal was depressed while approaching a speed pump and the vehicle unintendedly accelerated and drove at a high rate of speed before crashing into a fence. The contact stated that the vehicle had exceeded 40 MPH. During the crash, the front end of the vehicle was damaged; however, no air bags were deployed. The contact was not injured. The Police and EMS were called to the scene, and the driver and front seat passenger were examined. The driver and passenger suffered emotional stress from the crash. The cause of the failure was not yet determined. The manufacturer
Water leaking from the windshield seal (possibly the moonroof) gets into electronics under the dash and causes the transmission to stop working properly and also causes the engine to just stop completely. It happened 4 years ago and Volvo replaced a module but it happened again a week ago.
The dashboard lights go out for no reason. It is really dangerous at night when you have no speed showing and can't use the GPS system when navigating at night. This has been going on now for 2 years and still no fix. Last time in the shop for issue and Volvo service said no issues showing. Used a 2025 loaner while they worked on my car and the new car had the same issue so and ongoing issue that is not being addressed by Volvo.
My air conditioning system failed. The entire dashboard and front seats had to be removed. This included having to replace the A/C evaporator, evacuated A/C refrigerant system, removed center console, removed dshboard and all related components, removed and replaced evaporator, adapter for evaporator, o-rings at expansion valve, reinstalled wiring harness behind dash board and all related clips, Recharged A/C refrigerant system, Additionally, I continually received a power steering disable notification, and parking assist disable notification. This is so frustrating.
When I had to slow down or suddenly stop because there were other cars in front of me, I. stepped on the break, but it did not stop; maybe it slowed down a little, but the acceleration seemed to accelerate faster. I could hear the acceleration sound. I had to push the gear to stop. The car finally stopped. But I almost hit the front car. Similar occurrences happened when I came to a stop signal, which could have involved me in a serious accident, even fatal. I still drive the car because I have only one car. Most of the time, it works normally, but the problem occurs occasionally. I am scared, thinking it will happen again.
2018 Volvo XC60 questions
Does the 2018 Volvo XC60 have any recalls?
Yes. NHTSA lists 5 safety recalls for the 2018 Volvo XC60: Loose Front Seat Bolts Could Fail to Restrain Occupants; Loose Front Wiper Nuts Can Impair Windshield Visibility; Front seats may lack nuts, raising crash injury risk; Tailgate Lift Arms May Separate in Cold Weather; Software error may block GPS location for emergency crews. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2018 Volvo XC60?
Based on 36 owner complaints filed with NHTSA, the most-reported problem areas are Electrical System (11), Service Brakes (7), Air Bags (5).
How do I check if a recall on my 2018 Volvo XC60 has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.