CarRecallWatchThe 2021 Kenworth T880 has 8 safety recalls on file with NHTSA.
Owners have filed 1 complaint with NHTSA.
The most-reported problem area is Service Brakes (1 report).
2021 Kenworth T880 recalls
Braking and stability systems may fail, raising crash risk
The electronic control unit (ECU) that runs the anti-lock brakes, traction control, electronic stability control, active cruise control and collision mitigation system can receive electrical noise or a weak signal.
Gear Shifter Connection Can Fail, Disabling Truck After Stop
A right-hand gear shifter stalk connector may have been improperly crimped, which can cause a loss of communication between the gear shifter and the transmission.
Insufficient Air Tank Volume Can Weaken Brakes
Certain Kenworth trucks were built with air tanks that do not hold enough air for the brake system.
Methane alarm may fail if power is lost, risking fire
Certain heavy-duty trucks have a wiring defect in the methane detection system.
Brakes May Release During Winching, Causing Rollaway
On certain heavy-duty wrecker and auto hauler trucks, the work brake used during winching can unintentionally disengage the service brakes.
Fuel leak from rail assembly can cause fire
A sealing washer in the high-pressure fuel rail assembly may not seat correctly in the pilot bore holes.
Engine Flywheel Can Detach, Causing Power Loss
The capscrews attaching the flywheel to the crankshaft may have been improperly torqued, so the flywheel can come loose from the engine.
Loose Suspension Bolts Can Detach and Create Road Hazards
Some trucks have lower rear pivot bolts on the steerable lift axle suspension that are too short.
Most common 2021 Kenworth T880 problems
Problem areas named in the 1 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Service Brakes | 1 |
What owners report
TRACTOR ABS SYSTEM APPLIES THE BRAKES TO THE TRAILERS WHILE CORNERING CAUSING THE VEHICLE TO BECOME UNCONTROLLABLE. THIS USUALLY OCCURS WHILE ENTERING OR EXITING A HIGHWAY AT SPEEDS ABOVE 30 MPH. THE ABS SYSTEM LOCKS UP THE BRAKES UNTIL THE TRACTOR AND TRAILERS COME TO A COMPLETE STOP. THESE TRUCKS AND TRAILERS WEIGH APPROXIMATELY 155,000 LBS., AND LOSING CONTROL IS A SAFETY HAZARD FOR ANYONE ON THE ROAD. THESE TRUCKS ARE 2021 MODELS WITH BENDIX ABS SYSTEMS. THIS ISSUE HAS BEEN BROUGHT TO THE ATTENTION OF KENWORTH (THE VEHICLE MANUFACTURE) AND BENDIX (THE ABS SYSTEM MANUFACTURE). LITTLE HAS BEEN DONE TO RECTIFY THIS SAFETY ISSUE. THIS HAS BEEN HAPPENING SENSE THE TRACTORS WERE PUT INTO SE
2021 Kenworth T880 questions
Does the 2021 Kenworth T880 have any recalls?
Yes. NHTSA lists 8 safety recalls for the 2021 Kenworth T880: Braking and stability systems may fail, raising crash risk; Gear Shifter Connection Can Fail, Disabling Truck After Stop; Insufficient Air Tank Volume Can Weaken Brakes; Methane alarm may fail if power is lost, risking fire; Brakes May Release During Winching, Causing Rollaway. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2021 Kenworth T880?
Based on 1 owner complaint filed with NHTSA, the most-reported problem areas are Service Brakes (1).
How do I check if a recall on my 2021 Kenworth T880 has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.