CarRecallWatchThe 2015 RAM 3500 has 14 safety recalls on file with NHTSA.
Owners have filed 137 complaints with NHTSA, including 3 crashes, 5 fires, 1 injury.
The most-reported problem area is Power Train (32 reports).
2015 RAM 3500 recalls
Curtain Air Bag Inflator May Fail and Injure Occupants
Certain Ram pickups have a side curtain air bag inflator whose end cap can detach, or whose inflator housing can rupture.
Wrong lug nut torque spec can break wheel studs
Some RAM 3500, 4500, and 5500 trucks and cab chassis were built with incorrect torque information in the Service and Owner's Manuals.
Tailgate Can Unlatch and Open While Driving
A plastic limiter tab in the power tailgate actuator may crack or fracture.
Steering Link Can Separate, Causing Loss of Steering Control
The steering linkage jam nut on the outboard end of the drag link can loosen over time.
Tailgate Can Unlatch and Open While Driving
Some pickup trucks with a power locking tailgate and a 5 foot 7 inch or 6 foot 4 inch bed may have a tailgate actuator limiter tab that can fracture.
Cruise Control May Not Shut Off, Raising Crash Risk
A short circuit in the wiring can stop the cruise control from disengaging, whether by pressing the brake pedal or switching the system off manually.
Fire Extinguisher May Clog or Fail to Discharge
Some in-vehicle Kidde fire extinguishers, sold with certain Chrysler, Dodge, and RAM vehicles, may become clogged.
Transmission can shift out of Park without brake pedal
A brake interlock pin in the column-shift transmission can stick in the open position after the brake pedal is pressed for a long time while the vehicle is running and in Park.
Leaking Water Pump Can Cause Engine Fire
Certain RAM 2500, 3500, 4500, and 5500 trucks with 6.7L Cummins diesel engines may have Concentric-brand water pumps that lack a vent hole.
Aluminum wheels can crack and cause sudden air loss
Certain heavy-duty trucks that were modified by an aftermarket company to use cast aluminum Katla 8.5-inch road wheels may have wheels whose outer surface can fracture.
Side Curtain Airbags and Seatbelt Pretensioners May Not Deploy
Certain pickup trucks may have a fault in their Occupant Restraint Controller triggered by a roll rate sensor.
Steering may respond poorly if front bracket separates
Certain 2015 RAM 2500 and RAM 3500 trucks and cab chassis may have inadequate welds securing the front track bar frame brackets.
Radio software flaw could let hackers control vehicle systems
The radio in these vehicles contains software vulnerabilities that can allow outside parties to access certain networked vehicle control systems.
Side Airbags May Deploy Unexpectedly, Raising Crash Risk
Some 2013-2015 Ram 1500, 2500, and 3500 trucks may have side impact sensors that are overly sensitive.
Most common 2015 RAM 3500 problems
Problem areas named in the 137 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Power Train | 32 |
| Engine | 28 |
| Service Brakes | 24 |
| Steering | 22 |
| Electrical System | 19 |
| Suspension | 17 |
| Wheels | 15 |
| Unknown Or Other | 14 |
| Fuel/Propulsion System | 6 |
| Vehicle Speed Control | 6 |
What owners report
I own a 2015 Ram 3500 equipped with the 6.7L Cummins diesel engine. An authorized Ram dealership diagnosed an engine oil leak originating from the timing gear housing-to-engine block/cylinder block gasket. The leak has progressed beyond minor seepage. Engine oil is traveling down onto the chassis/track bar area and is leaving drops on the ground. The dealer estimated the repair at approximately $4,000 because of the extensive labor required to access and reseal the timing gear housing. My concern is that an engine oil leak from this sealed housing may worsen over time and could potentially result in significant oil loss, contamination of nearby chassis components, or oil reaching hot engine/
The contact owns a 2015 Ram 3500. While attempting to have an alignment performed, the contact was informed that the steering drag link and the tie rod were both cracked. The failure caused rapid, premature wear on the tire. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 19V021000 (Steering); and believed that the welding that was performed in the recall repair had directly caused the current failure. The vehicle was taken to an authorized dealer, where the technicians diagnosed the vehicle and determined that the previous recall repair made it impossible to perform a proper wheel alignment. The vehicle was not repaired. The manufacturer was notified
The output voltage to the Trailer Braking system is low, only 7.5 volts. Other owners have the same problem. From what I understand there is an issue with the computer that keeps the Original Equipment trailer brake controller from delivering full power at speeds below 30 MPH. This is a safety hazard in stop and go driving. There are many complaints about this same problem in the Ram Forumz. Ram should be able to do a software update to fix the problem. One of the posts in the forum stated that Ram has the software update available but will charge a lot of money for it. This is a safety issue and these trucks should be recalled to fix the problem.
humming from the hydroboost pump, actual issue is the high pressure steering line has a nylon tube inside the hose that breaks apart and moves throughout the system. Dodge had one revision of the hose on the early model years but this issue has gone unresolved. I am afraid if i cant get it fixed it may possibly cause the brakes or steering assistance to fail.
The contact owns a 2015 Ram 3500. The contact stated while driving approximately 70 MPH in the left lane, the check engine warning light illuminated, and the vehicle simultaneously went into LIMP Mode. The contact was able to pull over to the shoulder of the roadway. The contact was able to continue driving, but the vehicle failed to exceed 5 MPH. Upon arriving to the residence, the vehicle was scanned, and it was determined that the turbo charger actuator had failed and needed to be replaced. The contact purchased an aftermarket part and repaired the vehicle. The dealer was not contacted. The contact later became aware that the failure was related to Chrysler Extended Warranty Coverage Numb
2015 RAM 3500 questions
Does the 2015 RAM 3500 have any recalls?
Yes. NHTSA lists 14 safety recalls for the 2015 RAM 3500: Curtain Air Bag Inflator May Fail and Injure Occupants; Wrong lug nut torque spec can break wheel studs; Tailgate Can Unlatch and Open While Driving; Steering Link Can Separate, Causing Loss of Steering Control; Tailgate Can Unlatch and Open While Driving. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2015 RAM 3500?
Based on 137 owner complaints filed with NHTSA, the most-reported problem areas are Power Train (32), Engine (28), Service Brakes (24).
How do I check if a recall on my 2015 RAM 3500 has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.