CarRecallWatchMay 16, 2016
Clutch Spring Can Break, Causing Loss of Gear Shifting
Fiat 500 2012–2016
Certain Fiat 500 vehicles with a manual transmission may have a clutch diaphragm spring that can fracture and fail.
Power Loss Can Occur, Raising Crash Risk
Fiat 500e 2013–2016
The power inverter module in certain Fiat 500e electric vehicles may experience voltage spikes.
Propane tank may detach from trailer, raising crash risk
Jayco Travel Trailer JAY Flight SLX 2016
Some trailers from this production run may be missing lock washers on the two bolts that secure the propane tank to the A-frame.
Rear Wheel Lock Nuts May Loosen, Raising Crash Risk
Mercedes-Benz SLK300 2016
Some 2016 SLK300 vehicles built between January 19, 2016 and April 19, 2016 may have improperly manufactured lock nuts on the rear wheel tie rod connection.
Loose bearing bolts can cause boom to move unexpectedly
Altec Digger Derrick 2014–2016
Certain 2014-2016 Altec Digger Derrick trucks, built between October 2014 and April 2016 with the digger boom mounted in the corner, may have rotation bearing fasteners that were not properly torqued.
May 13, 2016
Rear axle nuts can loosen and detach, risking crash
Quality Equipment Flatbed Trailer 2015Quality Wedge CAR Hauler 2015
Certain 2015 Quality Equipment flatbed and Wedge car hauler trailers, built between April 1, 2015 and April 30, 2016, may have lock nuts that were not properly crimped.
Driver seat belt may detach in a crash, risking injury
Supreme Classic American Trolley 2010–2016
Certain 2010-2016 Classic American Trolley vehicles built between November 19, 2010 and January 29, 2016, and equipped with Recaro Ergo-M Commercial Bus Driver Seats, may have J-Brackets that are missing welds.
Entry Steps May Detach and Become Unstable
Supreme Ponyxpress 2007–2009Supreme Silver Crown 2007–2009
Some 2007-2009 Supreme Ponyxpress and Silver Crown vehicles have electrically powered entry steps that can malfunction.
May 12, 2016
Fire Pump Intake Strainer May Come Apart Mid-Use
E-One Cyclone II 2015–2016E-One Quest II 2015–2016E-One Typhoon 2015–2016
The intake strainers on the fire pumps may have been improperly soldered during production.
Pump intake strainer may detach, reducing firefighting capability
KME Predator Panther 2016–2017KME Predator SS 2016–2017KME Predator 2016+2 more models
Certain emergency fire vehicles were built with 6-inch pump intake strainers that may have been improperly soldered at the factory.
Seats May Separate From Base in a Crash
Champion Challenger 2016
Certain 2016 Champion Bus Challenger shuttle buses, built between January 29 and April 4, 2016, have seats that may separate from the base frame because of bolt failure.
Roof marker light short can cause fire in corner cap
Supreme Iner-City 2011–2014Supreme Kold King 2011–2014Supreme Signature Van 2011–2014
Certain roof marker lights on these vans and truck bodies are mounted on composite corner caps.
May 11, 2016
Right axle shaft can break without warning, risking crash
Jeep Cherokee 2016
Certain 2016 Jeep Cherokee vehicles built between October 3, 2015 and March 22, 2016 may have a right halfshaft that was incorrectly manufactured.
Loose Front Sway Bar Can Cause Loss of Steering Control
Forest River Berkshire 2016–2017Coachmen Cross Country 2016
The front sway bar mounting brackets may not fit properly on the axle.
Rear Guard May Not Protect in a Rear Crash
Great Lakes Drywall PUP 1998–2016
The rear impact guard on certain Drywall Pup trailers does not extend within 4 inches of the side of the trailer, so the trailer does not meet federal rear impact protection requirements (FMVSS 224).
Left Axle Shaft May Break Without Warning
Jeep Cherokee 2016
Certain 2016 Jeep Cherokee vehicles built between September 30 and October 2, 2015, may have a left halfshaft that was manufactured incorrectly.
Driver Air Bag May Fail to Deploy in a Crash
Jeep Wrangler 2011–2016
Some 2011-2016 Jeep Wranglers built with right-hand drive may have a clockspring assembly that becomes contaminated with dust.
Wrong load capacity label may lead to overloading and tire failure
Pacific Coachworks Rage'N 2016
The Federal Information label on certain 2016 toy haulers may list an incorrect Cargo Carrying Capacity (CCC) value.
Driver Air Bag May Not Deploy in a Crash
Jeep Wrangler 2007–2010
The clockspring assembly in the steering column can become contaminated with dust, which may cause the driver's frontal air bag circuit to fail.
Trailer axles may be overloaded and fail, raising crash risk
Keystone Passport 2016–2017
Certain 2016-2017 Keystone Passport recreational trailers (model 3350BHWE, built January 6, 2016 to April 21, 2016) were equipped with rear axles rated at 3,500 pounds instead of the required 4,400-pound capacity.
Steering Column May Fail, Causing Loss of Steering Control
Subaru Outback 2015–2017Subaru Legacy 2016–2017
The steering column on certain vehicles may have been improperly machined.
May 10, 2016
Crane valve cover can crack and fall off while driving
Elpers Dodge 5500 W/ Crane 2013–2016Elpers Ford F-450 W/ Crane 2013–2016Elpers Ford F-550 W/ Crane 2013–2016+4 more models
Certain trucks with IMT cranes have a valve bank cover that may crack and detach from the crane while the crane is being transported.
Front Sway Bar May Loosen and Detach, Hurting Handling
Itasca Meridian 2016Itasca Solei 2016Winnebago Forza 2016+1 more model
The front sway bar mounting brackets in certain motor homes may not fit properly on the axle.
Frame may rub front tire, risking blowout and steering loss
Holiday Rambler Endeavor 2016–2017Holiday Rambler Endeavor XE 2016–2017
Some motor homes have a section of framework that can rub against the front passenger-side tire, or cause the mud flap to rub it.
Rear shock may leak oil and lose function, raising crash risk
KTM 1290 Super Adventure 2015–2016
The rear shock absorber can leak oil from its rebound damping plug.
Power steering hoses can fail, causing sudden loss of steering assist
Newmar Essex 2014–2015Newmar London Aire 2015Newmar Mountain Aire 2015
Power steering fluid in these motorhomes can get hotter than the power steering hoses are rated for.
Seats May Separate From Base in a Crash
Turtle TOP Odyssey 2016
Certain 2016 Turtle Top Odyssey transit buses, built between December 17, 2015 and March 29, 2016, have seats that may separate from the base frame because of bolt failure.
Loose TV Bracket Could Let Trailer TV Fall
Keystone Outback 2016–2017
Certain 2016-2017 Keystone Outback trailers may have a television mounting bracket that is not properly secured to the wall.
Engine may shut off while riding, raising crash risk
Harley-Davidson Fxdl 2014–2016
Engine vibration can internally damage the ignition switch on certain Dyna Low Rider motorcycles built from January 6, 2014 to April 7, 2016.
May 9, 2016
Lift Gate Power May Stay On After Breaker Is Pushed
Utilimaster Aeromaster 2012–2015
The push-to-trip circuit breaker for the lift gate system may have been wired incorrectly.