1992 Plymouth Grand Voyager Recalls, Problems & Safety Rating

1992 Plymouth Grand Voyager recalls

Most common 1992 Plymouth Grand Voyager problems

Problem areas named in the 244 complaints owners filed with NHTSA.

Problem area	Reports
Seat Belts	62
Service Brakes, Hydraulic	55
Power Train	40
Structure	35
Engine And Engine Cooling	14
Steering	14
Visibility	14
Fuel System, Gasoline	11
Air Bags	10
Electrical System	8

What owners report

2018-08-16, Service Brakes
TL* THE CONTACT OWNS A 1992 PLYMOUTH GRAND VOYAGER. WHILE DRIVING VARIOUS SPEEDS, EXCESSIVE FORCE HAD TO BE APPLIED TO THE BRAKE PEDAL TO STOP THE VEHICLE. THE FAILURE OCCURRED WITHOUT WARNING. LODI CHRYSLER JEEP DODGE RAM (1255 BECKMAN RD, LODI, CA) DIAGNOSED THAT THE ABS PUMP MODULE ASSEMBLY AND BRAKE ACTUATOR ASSEMBLY FAILED. THE PARTS WERE INCLUDED IN A LIFETIME CHRYSLER CUSTOMER SATISFACTION CAMPAIGN NUMBER: 682; HOWEVER, THE PARTS WERE UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFUSED TO HONOR THE CAMPAIGN BECAUSE THEY NO LONGER MANUFACTURED THE PARTS FOR THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 189,000.

2014-11-01, Service Brakes
THIS VAN IS AFFECTED BY THE 96V099000 NHTSA RECALL, HOWEVER WHEN INQUIRING ABOUT GETTING THE ABS MOTOR REPLACED AT A LOCAL DEALERSHIP I WAS TOLD THAT THE PARTS ARE NO LONGER MADE TO FIX THIS ISSUE. I BELIEVE THAT CHRYSLER HAS A DUTY TO FIX THE BRAKES ON THIS VEHICLE AS DIRECTED BY THE NHTSA, PARTS OBSOLESCENCE DOES NOT ABSOLVE THEM FROM RESPONSIBILITY OR THE NHTSA. IF THE PARTS ARE NO LONGER AVAILABLE I REQUEST THAT CHRYSLER PURCHASE THE VAN BACK FROM ME AND HAVE IT DESTROYED, FIX THE BRAKES ACCORDING TO THE RECALL OR CONVERT THE BRAKES TO THE NON-ABS TYPE. I DO NOT UNDERSTAND HOW CHRYSLER AND THE NHTSA COULD ALLOW BENDIX (THE MANUFACTURER OF THIS RATHER PROBLEMATIC BRAKE SYSTEM) TO STOP

2013-06-24, Structure
WHILE DRIVING AT APPROXIMATELY 40 MPH, THE SPARE TIRE FELL FROM UNDER THE VAN. *TR

2012-11-06, Service Brakes
EXPERIENCED HARD BRAKE PEDAL (LOSE OF BRAKING) AND BRAKE / ABS LIGHTS ILLUMINATED ON THE DASH BOARD. THIS WAS THE SECOND FAILURE IN THE LAST TWO YEARS AFTER APPROXIMATELY 14,000 MILES OF OPERATION SINCE THE LAST REPAIR AND FOR AT LEAST THE FOURTH TIME SINCE WE HAVE OWNED THIS VEHICLE (BOUGHT NEW). PREVIOUS REPAIR INVOLVED REPLACEMENT OF BRAKE ACCUMULATOR, DUAL PRESSURE SWITCH, BRAKE ACTUATOR PISTON ASSEMBLY, AND THE PUMP MOTOR ASSEMBLY, THE LAST TWO OF WHICH ARE SUBJECT TO A LIFETIME RECALL. DEALER REFUSES TO REPAIR/REPLACE WARRANTED PARTS WITHOUT AGREEMENT THAT OTHER PARTS ARE REPLACED AT A COST OF APPROXIMATELY $900. GIVEN THAT IT IS LIKELY THAT WARRANTED PART FAILURES ARE LEADING TO

2011-12-06, Structure
TL* THE CONTACT OWNS A 1992 PLYMOUTH GRAND VOYAGER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH, THERE WAS A LOUD NOISE COMING FROM THE VEHICLE. AFTER PULLING OVER SHE NOTICED THAT THE FUEL RAIL WAS FRACTURED AND PARTIALLY HANGING FROM THE VEHICLE. IN ADDITION, THE SLIDING PASSENGER SIDE DOOR WOULD SPORADICALLY COME OFF TRACK AND COULD NOT BE CLOSED PROPERLY. THE DOOR WAS CLOSED USING A CORD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED HER THAT THEY WOULD HAVE TO TAKE THE DOOR APART FOR REALIGNMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE, STATING THAT THERE WERE NO RECALLS ON THE VEHICLE. THE FAILURE

1992 Plymouth Grand Voyager questions

Does the 1992 Plymouth Grand Voyager have any recalls?

Yes. NHTSA lists 6 safety recalls for the 1992 Plymouth Grand Voyager: Visibility:Windshield Wiper/Washer:Linkages; Seat Belts:Front:Buckle Assembly; Seat Belts:Front:Anchorage; Structure:Body:Hatchback/Liftgate:Support Device/Strut; Steering: Steering Wheel/Handle Bar. Recall repairs are normally free at an authorized dealer.

What are the most common problems with the 1992 Plymouth Grand Voyager?

Based on 244 owner complaints filed with NHTSA, the most-reported problem areas are Seat Belts (62), Service Brakes, Hydraulic (55), Power Train (40).

How do I check if a recall on my 1992 Plymouth Grand Voyager has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.