CarRecallWatchThe 2009 Mazda MAZDA6 has 9 safety recalls on file with NHTSA.
Owners have filed 386 complaints with NHTSA, including 8 crashes, 3 fires, 5 injuries.
The most-reported problem area is Structure (124 reports).
2009 Mazda MAZDA6 recalls
Passenger Airbag Inflator May Explode, Injuring Occupants
The passenger frontal airbag inflator in these vehicles was previously replaced under an earlier recall, but the replacement uses the same design.
Road Salt Can Weaken Front Suspension, Risking Crash
Road salt can cause corrosion in the front cross member of certain 2009-2010 Mazda MAZDA6 vehicles.
Passenger airbag inflator may explode, sending metal fragments into occupants
Certain Mazda vehicles have a passenger-side frontal airbag inflator that can rupture during a crash that deploys the airbag.
Passenger Airbag Inflator May Rupture and Spray Metal Fragments
The passenger-side frontal airbag inflator in these vehicles can rupture in a crash that deploys the airbag.
Passenger Air Bag Inflator May Rupture in a Crash
The passenger-side frontal air bag inflator in these vehicles can degrade over time from long-term exposure to humidity and temperature changes.
Air Bag Control Unit May Fail, Blocking Air Bag Deployment
The protective coating on the air bag control unit may not have been properly applied at the factory.
Most common 2009 Mazda MAZDA6 problems
Problem areas named in the 386 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Structure | 124 |
| Suspension | 76 |
| Air Bags | 75 |
| Unknown Or Other | 57 |
| Steering | 37 |
| Electrical System | 33 |
| Wheels | 16 |
| Exterior Lighting | 15 |
| Tires | 14 |
| Visibility/Wiper | 14 |
What owners report
Rear cross member broke due to corrosion breaking off lateral arm from driver side of cross member, I may add the front crossmember was repaired due to recall for extreme corrosion not too long ago, as I research this problem I uncover many owners of this vehicle having the same issue in the northeast,even with much lower mileage.mazda should be held accountable.$3,926.62 for part alone on Mazda parts.com
The rear subframe rusted out and my control arm broke off! This is extremely serious and because there is no recall Iâm going to have to buy an another vehicle. Please issue a recall. Iâve read forms about this and many others have had the same issue with the rear subframe corroding and rotting out.
My rear subframe rusted thru and has holes in it. It is too dangerous to drive and mazda won't recall the rear like the front subframe knowing that a lot of people are suffering from the same issue. A subframe should last a long time. My mechanic inspected the car and feels like it's not safe to drive.
This car was purchased in 2017 and maintenanced regularly. We recently took it to have the oil changed and to check out a noise that was coming from the passenger side. We were told that the subframe was rusted so badly it was too dangerous to drive and would cost $7k to repair. That caught us by surprise and we ended up having to buy a car by the next day. We traded the car in⦠However, I started doing some research and noted that this is very common and there was a recall between 2010 and 2014. Iâm pretty upset that we lost this car without having any recall notification after the purchase. Could this have been taken care of instead of having to get a new car?
Component or System that Failed: The front subframe on my 2009 Mazda 6i Touring is completely rusted through. There are holes in the frame and large flakes of rusted metal breaking off. The car is available for inspection if needed. Safety Risk: This is a serious safety concern because if the subframe fails, I could lose steering or suspension control while driving. That would put me and other drivers at immediate risk of an accident. Reproduction / Confirmation: An independent mechanic confirmed the problem and told me the car is unsafe to drive in its current condition. Inspection: The vehicle had the original Mazda subframe corrosion recall performed years ago, but now the same exact p
2009 Mazda MAZDA6 questions
Does the 2009 Mazda MAZDA6 have any recalls?
Yes. NHTSA lists 9 safety recalls for the 2009 Mazda MAZDA6: Passenger Airbag Inflator May Explode, Injuring Occupants; Road Salt Can Weaken Front Suspension, Risking Crash; Passenger airbag inflator may explode, sending metal fragments into occupants; Passenger Airbag Inflator May Rupture and Spray Metal Fragments; Passenger Air Bag Inflator May Rupture in a Crash. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2009 Mazda MAZDA6?
Based on 386 owner complaints filed with NHTSA, the most-reported problem areas are Structure (124), Suspension (76), Air Bags (75).
How do I check if a recall on my 2009 Mazda MAZDA6 has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.