CarRecallWatchThe 2006 Mazda MAZDA6 has 3 safety recalls on file with NHTSA.
Owners have filed 173 complaints with NHTSA, including 13 crashes, 1 fire, 8 injuries.
The most-reported problem area is Air Bags (95 reports).
2006 Mazda MAZDA6 recalls
Passenger airbag inflator may explode, causing injury
The passenger-side frontal airbag inflator in these vehicles can degrade over time after long exposure to high humidity, heat and temperature changes.
Passenger airbag inflator may explode, causing injury
The front passenger airbag inflator in these Mazda vehicles can explode during a crash that deploys the airbag.
Driver's airbag inflator may rupture in a crash
The driver's frontal airbag inflator in these vehicles can be affected by moisture and manufacturing variation, which over time could cause it to rupture when the airbag deploys.
Most common 2006 Mazda MAZDA6 problems
Problem areas named in the 173 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Air Bags | 95 |
| Power Train | 21 |
| Electrical System | 11 |
| Engine | 10 |
| Engine And Engine Cooling | 9 |
| Steering | 7 |
| Tires | 7 |
| Structure | 7 |
| Exterior Lighting | 7 |
| Vehicle Speed Control | 5 |
What owners report
The front beam crossmember sub k frame of this vehicle has failed due to corrosion. This has resulted in a loss of steering control. Fortunately his failure was discovered while the vehicle was parked or it could have resulted in a very serious vehicle accident. There was an acknowledgment (and recall) of this corrosion failure issue issued by Mazda but it was for a subsequent model years. I contacted Mazda regarding this very dangerous issue and they denied any responsibility.
The contact owns a 2006 Mazda Mazda6. The contact stated that while the vehicle was at the local service center for maintenance, it was discovered that rust and corrosion was present on the front passengerâs side lower control arm. The vehicle was not yet repaired. The local dealer was notified of the failure and informed that the model year was not included in a Manufacturer's recall for the same failure. The manufacturer was not contacted. The failure mileage was 142,000.
Car is mint for age. Stock oem hid style headlights failed, headlights are still clear. The turn signals failed and activated safetys. Ground plug under air filter assembly that is a piece of metal bolted to car with 5 wires that plug into it corroded so bad no ground connection and each of the wires made no connection to the plug. No info on how to diagnose and/or repair. Common problem. Took everything apart and soaked all corroded parts in a solution of CLR, everything put back together clean with dielectric grease. Numerous shops could not diagnose including 1 dealer. Said headlights needed to be replaced at $500+/ side parts only. Very common on the rare factory installed HID systems. W
The contact owns a 2006 Mazda Mazda6. The contact stated when the vehicle was started, the engine made a loud ticking noise. The contact stated that once the vehicle had warmed up, the would drive normal; however, while driving 30 MPH, the check engine warning light illuminated and the vehicle stalled. The contact had taken the vehicle to an independent mechanic who diagnosed that the Variable Valve Timing Actuator (VVTA) was not functioning as needed causing the engine stall and loud ticking sound. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 123,000.
The contact owns a 2006 Mazda Mazda6. The contact received notification of NHTSA Campaign Number: 21V744000 (Fuel System, Gasoline) however, the nearest dealer that was able to perform the recall repair was 3-hours away. The contact had not experienced a failure. The manufacturer was made aware of the issue and suggested that the vehicle be taken or towed to the dealer for the free one-time repair. The vehicle was not yet repaired. THE CONSUMER EXPRESSED CONCERN WITH INCURRED COST ASSOCIATED WITH THE RECALL.
2006 Mazda MAZDA6 questions
Does the 2006 Mazda MAZDA6 have any recalls?
Yes. NHTSA lists 3 safety recalls for the 2006 Mazda MAZDA6: Passenger airbag inflator may explode, causing injury; Passenger airbag inflator may explode, causing injury; Driver's airbag inflator may rupture in a crash. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2006 Mazda MAZDA6?
Based on 173 owner complaints filed with NHTSA, the most-reported problem areas are Air Bags (95), Power Train (21), Electrical System (11).
How do I check if a recall on my 2006 Mazda MAZDA6 has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.