2007 Harley-Davidson Flhtc Recalls, Problems & Safety Rating

2007 Harley-Davidson Flhtc recalls

No safety recalls on file for the 2007 Harley-Davidson Flhtc.

Most common 2007 Harley-Davidson Flhtc problems

Problem areas named in the 14 complaints owners filed with NHTSA.

Problem area	Reports
Engine And Engine Cooling	6
Power Train	5
Exterior Lighting	2
Electrical System	1
Tires	1
Service Brakes	1

What owners report

2016-12-29, Power Train
TL* THE CONTACT OWNS A 2007 HARLEY-DAVIDSON FLHTC. WHILE RIDING 75-80 MPH, AN ABNORMAL NOISE EMITTED FROM THE TRANSMISSION. THE DEALER DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE MOTORCYCLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000. UPDATED 04/06/17 LJ *TR

2014-09-28, Service Brakes
THE REAR BRAKE LINE (PN 40971-00A) RUBBED THE FRAME AND CLUTCH CABLE, CAUSING A HOLE TO BE CREATED. THIS IS IN THE AREA BELOW THE CAM CHEST, BEHIND THE MASTER CYLINDER, INSIDE THE FRAME ON THE RIGHT SIDE. THE BRAKE LINE BLEW OUT WHEN THE REAR BRAKE WAS APPLIED. THERE WAS NO WARNING. AFTER DOING RESEARCH, I FOUND THIS TO BE A COMMON PROBLEM. *TR

2014-09-05, Exterior Lighting
TL* THE CONTACT OWNS A 2007 HARLEY DAVIDSON FLHTC. THE CONTACT STATED THAT WHILE DRIVING AT 9 MPH, THE BRAKE LAMP FAILED TO ACTIVATE WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT MENTIONED THAT THE BRAKE LAMP SWITCH WAS MELTED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE LIGHT SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN NUMBER WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V506000 (EXTERIOR LIGHTING). THE FAILURE MILEAGE WAS 43,000.

2014-07-24, Power Train
AS I WAS SLOWING DOWN IN MY DRIVEWAY THE ENGINE, WITH OUT WARNING, MADE A LOUD METALLIC NOISE FROM THE LEFT SIDE AND LOCKED UP ALONG WITH THE REAR WHEEL. IF THIS WOULD HAVE HAPPENED AT A GREATER SPEED, OR IN TRAFFIC, THE CONSEQUENCES COULD HAVE BEEN DIRE. I REMOVED THE PRIMARY COVER AND IMMEDIATELY NOTICE A LARGE PIECE OF STEEL HAD GOTTEN JAMMED BETWEEN THE CLUTCH SPROCKET AND PRIMARY DRIVE CHAIN. THIS LARGE PIECE OF STEEL HAD BROKEN OFF A PRESSED STEEL CAGE THAT ENCLOSED A SET OF DIAPHRAGM SPRINGS FROM THE CRANKSHAFT COMPENSATOR ASSEMBLY. THE OUTER EDGE OF THE SPRINGS, OVER TIME, HAD WORN THEIR WAY THROUGH THE CAGE THAT CONTAINS THEM IN PLACE CAUSING A SECTION OF THE CAGE TO SEPARATE.

2013-03-19, Tires
WHILE RIDING THE MOTORCYCLE (2007 HARLEY DAVIDSON HERITAGE SOFTAIL CLASSIC) AT 57 MPH ON DRY PAVEMENT WITH NO ADVERSE ROAD CONDITIONS, THE REAR TIRE BLEW, THE RIDER FOUGHT TO KEEP THE BIKE UPRIGHT TO SLOW DOWN FOR 3-5 SECONDS, THEN LOST CONTROL AND CRASHED ON THE HIGHWAY. THE TIRE PRESSURE WAS CHECKED TO PROPER INFLATION 30 MINUTES BEFORE THE BLOWOUT AND ACCIDENT OCCURRED. THE RIDER SUFFERED A BRAIN CONCLUSION WITH MINOR HEMORRHAGING, A BROKEN COLLARBONE, AND BROKEN BONES IN THE RIGHT FOOT. THE TIRE, WHICH WAS NEW ON THE BIKE AND PURCHASED TWO MONTHS BEFORE THE ACCIDENT, HAD ONLY BEEN RIDDEN FOR 1400 MILES. THE TIRE, BRIDGESTONE EXEDRA G702, APPEARS TO BE DEFECTIVE, HAVING COME APART A

2007 Harley-Davidson Flhtc questions

Does the 2007 Harley-Davidson Flhtc have any recalls?

No. NHTSA has no safety recalls on file for the 2007 Harley-Davidson Flhtc at this time.

What are the most common problems with the 2007 Harley-Davidson Flhtc?

Based on 14 owner complaints filed with NHTSA, the most-reported problem areas are Engine And Engine Cooling (6), Power Train (5), Exterior Lighting (2).

How do I check if a recall on my 2007 Harley-Davidson Flhtc has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.