CarRecallWatchThe 2025 Grand Design Lineage has 7 safety recalls on file with NHTSA.
Owners have filed 3 complaints with NHTSA.
The most-reported problem area is Fuel/Propulsion System (1 report).
2025 Grand Design Lineage recalls
Roof Solar Panels May Detach, Creating Road Hazard
Certain 2025 and 2026 Grand Design Lineage recreational vehicles may have solar panels bonded to the roof with adhesive that can fail.
Loose Seat Bases Could Shift in a Crash
Certain 2025-2026 Grand Design Lineage recreational vehicles may have driver and passenger seat bases that were not tightened properly.
Entry Steps May Extend While Driving, Raising Crash Risk
On certain 2025-2026 Grand Design Lineage motorhomes, the entry door position switch may not make adequate contact, so the system can fail to detect that the door is closed.
Loose Driver and Passenger Seat Bases Raise Crash Injury Risk
Certain 2025-2026 motorhomes may have had the driver and front passenger seat bases tightened improperly, so the seat base can become loose.
Roof Solar Panels Can Detach and Become a Road Hazard
The adhesive that holds the solar panels to the roof of certain 2025 and 2026 Grand Design Lineage recreational vehicles may fail.
Entry Door Latch Can Fail, Trapping Occupants
Certain 2025 and 2026 Grand Design Lineage recreational trailers equipped with Lippert Modularia entrance doors have a door latch mechanism that may fail.
Battery Warming Pad May Short Circuit and Cause Fire
A battery warming pad on certain motorhomes was installed incorrectly.
Most common 2025 Grand Design Lineage problems
Problem areas named in the 3 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Fuel/Propulsion System | 1 |
| Equipment | 1 |
| Latches/Locks/Linkages | 1 |
| Structure | 1 |
| Suspension | 1 |
What owners report
The contact owns a 2025 Ford F-600 SD. The contact stated that while driving at an undisclosed speed, the front of the vehicle raised up and the contact discovered that the vehicle, which had been converted into a motorhome, was improperly weighted, causing excessive weight on the rear axle. The contact stated that there was no clearance between the rear spring pack and the bump stop because the rear of the vehicle was significantly heavier than the front. The contact stated that the rear springs were resting on the frame of the vehicle. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that additional rear springs nee
The contact owns a 2025 Grand Design Lineage RV built on a 2024 Mercedes-Benz Sprinter 4500 Chassis. The contact had received notification of NHTSA Campaign Number: 25V473000 (EQUIPMENT, LATCHES/LOCKS/LINKAGES); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool showed no open recall.
On 6/30/25 I originally reported the Safety Issue (Case #11670309). The engine dies while driving. The display indicates "Low Fuel Pressure" and the Check Engine light comes on. The vehicle has been to the Ford Service Center several times for repair. They have validated the issue and have documented the DTS codes. Some components have been replaced or overlaid. My and other's safety has been put at risk. When the engine dies the vehicle has no power steering or power brakes. Pulling over to a safe location is difficult or not available. Most recent event occurred on 8/10/25.
2025 Grand Design Lineage questions
Does the 2025 Grand Design Lineage have any recalls?
Yes. NHTSA lists 7 safety recalls for the 2025 Grand Design Lineage: Roof Solar Panels May Detach, Creating Road Hazard; Loose Seat Bases Could Shift in a Crash; Entry Steps May Extend While Driving, Raising Crash Risk; Loose Driver and Passenger Seat Bases Raise Crash Injury Risk; Roof Solar Panels Can Detach and Become a Road Hazard. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2025 Grand Design Lineage?
Based on 3 owner complaints filed with NHTSA, the most-reported problem areas are Fuel/Propulsion System (1), Equipment (1), Latches/Locks/Linkages (1).
How do I check if a recall on my 2025 Grand Design Lineage has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.