CarRecallWatchThe 2016 Toyota Tundra has 5 safety recalls on file with NHTSA.
Owners have filed 120 complaints with NHTSA, including 2 crashes, 3 injuries.
The most-reported problem area is Service Brakes (34 reports).
2016 Toyota Tundra recalls
Power Steering Leak Can Cause Sudden Loss of Assist
The power steering gear assembly may have been manufactured incorrectly, which can allow oil to leak from the system.
Passenger Knee Airbag May Loosen and Not Deploy Properly
The passenger knee airbag module may have been attached to the instrument panel mounting brackets with incorrect bolts.
Lug nuts can crack and let wheels come off
Certain Toyota Tundra and Sequoia vehicles fitted with 20-inch Rockstar wheels installed by Southeast Toyota Distributors or a Southeast Toyota dealer may have lug nuts that crack and detach.
Rear bumper corner may break away when stepped on
A damaged resin rear step bumper bracket can go unnoticed after an impact to the corner of the bumper.
Incorrect load label may lead to vehicle overloading and crash risk
The Load Carrying Capacity Modification Label on certain vehicles may not reflect the correct added weight of installed accessories.
Most common 2016 Toyota Tundra problems
Problem areas named in the 120 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Service Brakes | 34 |
| Electrical System | 26 |
| Structure | 21 |
| Exterior Lighting | 15 |
| Unknown Or Other | 15 |
| Steering | 7 |
| Fuel/Propulsion System | 6 |
| Engine | 6 |
| Power Train | 5 |
| Air Bags | 4 |
What owners report
The contact owns a 2016 Toyota Tundra. The contact stated that upon starting the vehicle, the vehicle hesitated and shuddered. While driving approximately 65-70 MPH and depressing the accelerator pedal, the vehicle stalled. There was an unknown warning light was displayed after the failure. There was an abnormal fuel odor before and after the failure. The vehicle stalled and failed to restart and was towed. A service repair had been scheduled. Upon research the contact associated the failure with TSB: 0166-19. The failure mileage was approximately 77,000.
2016 flex fuel toyota tundra with 118,00 miles was towed to toyota dealer in Las cruces with a no fuel issue. After the analysis it was determined the fuel pump over heated burning out conector and wiring ,but the pump was still working. According to toyota TSB 0166-19 this is a problem the can arise if the alcohol fuel density ID is not updated. I told the dealer to due repairs on vehicle even though a fuel pump was installed and reflashed at 114,000 miles. Viva toyota of las cruses advicate stated that a reflash is all the vehiles needs and does not desire to change the alchol fuel density to updated ID as per TSB-0166-19, so I am worried I will be operating a vehicle with a fuel pump t
Bed is rusting out from the bottom in a fashion that looks very similar to a previous Tundra bed rusting issue that had a TSB and remedy from Toyota. On the driver's side bed bolt closest to the cab, the sheet metal tack welded to the bed has separated and is rusting out. Approximately 7 inches to the drivers side from that bolt. The seam sealer is also cracking. Additionally, the drivers side bed bolt closes to the tailgate has rust bubbling up from underneath approximately 1 inch to the passenger side from the bolt and also along where that sheet metal is tack welded onto the bed.
The fuel pump component or system failed or malfunctioned the engine tried cranking but would not start. The problem has been reproduced to an independent service center, where I was notified of a safety recall on Toyota Tundra. No other inspections have been performed. There are no warning lamps messages visible on the vehicle in question. The vehicle will not start until repeated starts are performed. Vehicle idles roughly before regaining normal idle. One other past similar incident of this type has occurred. No other
The contact owns a 2016 Toyota Tundra. The contact stated that while driving at slower speeds, the vehicle stalled while depressing the accelerator pedal. The check engine warning light was illuminated. The vehicle was towed to a local dealer to be diagnosed. The contact was informed that the fuel pump and other fuel pump-related parts needed to be replaced. The vehicle was not repaired because the parts were on back order. The manufacturer was made aware of the failure. The failure mileage was approximately 67,000.
2016 Toyota Tundra questions
Does the 2016 Toyota Tundra have any recalls?
Yes. NHTSA lists 5 safety recalls for the 2016 Toyota Tundra: Power Steering Leak Can Cause Sudden Loss of Assist; Passenger Knee Airbag May Loosen and Not Deploy Properly; Lug nuts can crack and let wheels come off; Rear bumper corner may break away when stepped on; Incorrect load label may lead to vehicle overloading and crash risk. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2016 Toyota Tundra?
Based on 120 owner complaints filed with NHTSA, the most-reported problem areas are Service Brakes (34), Electrical System (26), Structure (21).
How do I check if a recall on my 2016 Toyota Tundra has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.