CarRecallWatchThe 2021 Ford F-450 SD has 12 safety recalls on file with NHTSA.
Owners have filed 18 complaints with NHTSA, including 1 fire.
The most-reported problem area is Electrical System (6 reports).
2021 Ford F-450 SD recalls
Fuel pump can fail and cut engine power on diesel trucks
Some 2020 and 2021 Ford F-Super Duty diesel trucks (F-250, F-350, F-450 and F-550) that were previously repaired under an earlier recall may have biodiesel deposits forming on roller components inside the high pressure fuel pump's drivetrain.
Rearview camera may not show proper image in some light
Certain 2020-2022 Ford F-250, F-350, and F-450 Super Duty trucks have a 360-degree view camera system that may not display the rearview image properly in certain lighting conditions.
Steering Column May Detach, Causing Loss of Steering
Certain 2020-2021 Ford F-250, F-350, and F-450 Super Duty trucks may have a steering column upper shaft that can detach from the steering column.
Fuel pump can fail, causing engine stall while driving
The low-pressure fuel pump in certain vehicles may fail, which can cause the engine to stall while you are driving.
Rearview camera may show blank or distorted image
Some vehicles have a rearview camera that can display a blank or distorted picture.
Fuel pump may fail, causing loss of drive power
Biodiesel deposits can build up on rollers inside the diesel high pressure fuel pump drivetrain on certain Ford Super Duty trucks.
Missing Head Restraint Instructions Raise Crash Injury Risk
Some Ford Expedition, Lincoln Navigator, and F-Super Duty SuperCab trucks were built without owner's manual instructions for adjusting or removing certain head restraints, including those for the center seating positions.
Wiper Arms May Break, Losing Windshield Wipers
The front windshield wiper arms on these vehicles can break, causing the wipers to stop working.
Fuel leak from filter cap can cause fire or injury
A small void may form in the top-center of the underhood secondary fuel filter cap on certain diesel-equipped trucks.
Front Wheel Extenders May Detach, Raising Crash Risk
On certain heavy-duty trucks with dual rear wheels and front wheel hub extenders, the front wheel hub extenders may not be properly attached to the front rotor hub assemblies.
Fifth Wheel Bracket May Crack and Detach While Towing
A left-hand mounting bracket for the fifth wheel assembly may be cracked.
Windshield May Detach in a Crash, Raising Injury Risk
Some pickups and Super Duty trucks from the 2020 and 2021 model years may have had their windshield improperly bonded to the body during manufacturing.
Most common 2021 Ford F-450 SD problems
Problem areas named in the 18 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Electrical System | 6 |
| Power Train | 4 |
| Structure | 3 |
| Latches/Locks/Linkages | 2 |
| Unknown Or Other | 2 |
| Service Brakes | 2 |
| Engine | 2 |
| Fuel/Propulsion System | 2 |
| Trailer Hitches | 1 |
| Service Brakes, Hydraulic | 1 |
What owners report
Unknown. This vehicle when driving and come to a complete stop will jerk forward. It has been to 2 different ford dealerships to assist with this issue and has been "covered" under transmission control module recall and reprogrammed as per their invoices, but has not fixed the issue. It is currently at the 2nd dealership while they are furthering this inspection.
Failure of a $70 thermocouple sensor in the air conditioning unit requires replacement of the entire evaporative cooler, which requires removal and reinstallation of the entire dash from the vehicle. This should be a part serviceable without such extensive work.
Technician was airing the tires - zipper ruputer occured on the inside of the tire. 225/70R19.5
The contact owns a 2021 Ford F-450 SD. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
The contact owned a 2021 Ford F-450 Super Duty. The contact stated that while driving 35 MPH on an 8 percent decline and pulling a trailer, the vehicle slightly responded upon depressing the brake pedal. Additionally, the transmission failed to downshift and was stuck in 10th gear. The contact pumped the brakes; however, the failure persisted. The contact drove into the shoulder of the roadway, and the vehicle was able to stop. The contact noticed smoke, and upon inspecting underneath the vehicle, the contact noticed that the rear brakes were on fire. The contact was able to extinguish the fire with a fire extinguisher. There was no injury sustained. The vehicle was towed to the residence of
2021 Ford F-450 SD questions
Does the 2021 Ford F-450 SD have any recalls?
Yes. NHTSA lists 12 safety recalls for the 2021 Ford F-450 SD: Fuel pump can fail and cut engine power on diesel trucks; Rearview camera may not show proper image in some light; Steering Column May Detach, Causing Loss of Steering; Fuel pump can fail, causing engine stall while driving; Rearview camera may show blank or distorted image. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2021 Ford F-450 SD?
Based on 18 owner complaints filed with NHTSA, the most-reported problem areas are Electrical System (6), Power Train (4), Structure (3).
How do I check if a recall on my 2021 Ford F-450 SD has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.