CarRecallWatchThe 2021 Ford Bronco Sport has 16 safety recalls on file with NHTSA.
Owners have filed 712 complaints with NHTSA, including 18 crashes, 17 fires, 12 injuries.
The most-reported problem area is Electrical System (215 reports).
NHTSA rates it up to 5 stars overall for crash safety, depending on the version.
2021 Ford Bronco Sport recalls
Front Control Arm May Detach, Risking Loss of Control
Some Ford Bronco Sport and Maverick vehicles may have front lower control arm ball joints that were incorrectly installed or repaired at the assembly plant.
Engine Block Heater May Crack and Cause Fire Risk
The engine block heater can crack and develop a coolant leak.
Fuel Injector May Crack and Leak, Creating Fire Risk
A fuel injector in the engine can crack and leak gasoline inside the engine compartment.
Rearview Camera May Show Blank or Stuck Image
A software error can cause the rearview camera to display a blank image, or to keep showing the camera image after the vehicle has left reverse.
Low 12-Volt Battery Can Go Undetected, Risking Power Loss
Some vehicles were previously repaired under an earlier recall and may have body and power train control modules that fail to detect a change in the 12-volt battery's state of charge.
Fuel Injector May Crack and Leak, Creating Fire Risk
A fuel injector in these vehicles may crack and leak fuel inside the engine compartment.
12-Volt Battery May Fail Suddenly, Causing Loss of Power
Certain Ford Bronco Sport and Maverick vehicles may have a 12-volt battery that degrades and can suddenly fail.
Low 12-Volt Battery May Go Undetected, Risking Power Loss
Certain vehicles have body and power train control modules that may fail to detect a change in the 12-volt battery's state of charge.
Fuel injector can crack and leak, creating fire risk
A fuel injector on this vehicle's 1.5L engine may crack and leak fuel inside the engine compartment.
Oil leak can raise fire risk in 1.5L engine
The engine oil separator housing can crack and develop an oil leak.
Rear brake linings may reduce braking performance
Certain 2021-2022 Ford Bronco Sport and Escape vehicles may have rear brake linings that were manufactured incorrectly.
Moonroof Glass Can Detach While Driving
The moonroof glass on certain vehicles may not have been bonded correctly to the moonroof frame.
Fuel Pump Module Leak Can Cause Engine Stall
The fuel delivery module in these vehicles may leak inside the fuel tank.
Front Control Arm May Affect Handling, Raising Rollover Risk
Some vehicles may have been built with incorrect front lower control arms.
Loose rear suspension bolts can affect handling and crash risk
Some 2021 Bronco Sport vehicles may have loose or missing bolts in the rear suspension subframe assembly.
Low Rear Axle Lubricant Can Seize Drive Unit, Causing Loss of Control
The rear drive unit may not have enough lubricant, which can cause the rear drive axle to seize.
Most common 2021 Ford Bronco Sport problems
Problem areas named in the 712 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Electrical System | 215 |
| Power Train | 195 |
| Engine | 152 |
| Service Brakes | 101 |
| Unknown Or Other | 98 |
| Fuel/Propulsion System | 64 |
| Fuel System, Gasoline | 60 |
| Service Brakes, Hydraulic | 27 |
| Engine And Engine Cooling | 25 |
| Suspension | 24 |
What owners report
The contact owns a 2021 Ford Bronco Sport equipped with an 8F35 automatic transmission. While driving between 25 and 45 MPH under normal acceleration, the vehicle experienced repeated violent hesitation, jerking, and lunging 4 to 5 times in rapid succession, accompanied by rapid RPM fluctuations between 2,000 and 3,000 RPM. The condition mimics an engine misfire or momentary stall and loss of motive power during acceleration, creating an immediate safety hazard and risk of rear-end collision in active traffic. The vehicle was taken to an authorized Ford dealership (Cronin Ford North) on September 30, 2026. The dealership verified and duplicated the complaint on a road test, monitored PIDs,
Driving and check engine light came on saying abs system disabled pull over immediately This was a 4000.00 repair for the sensor that shouldâve been a recall as there were 5 other broncos repaired with this same issue in the shop during my repair. I was not covered u der warranty because I was 600 miles over power train warranty when this occurred. Please review for possible ford recall.
The contact owns a 2021 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while accelerating from a complete stop and while driving at various speeds, the vehicle intermittently failed to accelerate. The vehicle was taken to an independent mechanic, where it was determined that fuel was not reaching the engine. The dealer was contacted and informed the contact that there was no open recall on the VIN. The vehicle was no longer driven due to the safety issue. The contact stated that the manufacturer had exceeded a reasonable amount of time fo
The Bronco Sport was put into drive and would not go like normal, it slowly picked up speed, but every shift between gears was felt. The vehicle drove fine once it hit 55mph. Vehicle was shut off and then would not engage into drive. The drive icon was flashing. The dealer was able to confirm the problem. There were zero warning messages or symptoms prior to the problem. The vehicle had been serviced two months prior and the transmission was functioning in the green according to the dealer.
Vehicle had rough idle. Loss power. Loss engine coolant and oil and started pouring large amounts of white smoke from exhaust.
2021 Ford Bronco Sport safety rating
| Version | Overall | Frontal | Side | Rollover |
|---|---|---|---|---|
| 2021 Ford Bronco Sport SUV 4WD | ★★★★★ 5-star | 5 | 5 | 4 (17.4% rollover risk) |
2021 Ford Bronco Sport questions
Does the 2021 Ford Bronco Sport have any recalls?
Yes. NHTSA lists 16 safety recalls for the 2021 Ford Bronco Sport: Front Control Arm May Detach, Risking Loss of Control; Engine Block Heater May Crack and Cause Fire Risk; Fuel Injector May Crack and Leak, Creating Fire Risk; Rearview Camera May Show Blank or Stuck Image; Low 12-Volt Battery Can Go Undetected, Risking Power Loss. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2021 Ford Bronco Sport?
Based on 712 owner complaints filed with NHTSA, the most-reported problem areas are Electrical System (215), Power Train (195), Engine (152).
How safe is the 2021 Ford Bronco Sport?
NHTSA's 5-Star Safety Ratings program gives the 2021 Ford Bronco Sport up to 5 out of 5 stars overall; ratings vary by version, see the table above.
How do I check if a recall on my 2021 Ford Bronco Sport has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.