2006 Ford Explorer Recalls, Problems & Safety Rating

2006 Ford Explorer recalls

Most common 2006 Ford Explorer problems

Problem areas named in the 630 complaints owners filed with NHTSA.

Problem area	Reports
Power Train	301
Engine And Engine Cooling	169
Engine	58
Electrical System	39
Vehicle Speed Control	28
Service Brakes, Hydraulic	23
Unknown Or Other	22
Fuel System, Gasoline	18
Visibility	15
Service Brakes	14

What owners report

2025-05-27, Power Train
Hi, I purchased my 2006 ford explorer in 2019 from a mechanic lot. Since then I’ve changed the muffler, all 4 of the o2 sensors. Recently, after changing parts like the cylinder, spark plugs and wires as well as another set of o2 sensors and the EGR Valve, Mass Air flow sensor and the EGR sylenoid valve I have been getting check engine light with the emissions code not passing inspection. At this point my registration is at hand and the mechanics that change the parts can’t seem to understand why the check engine light did not go off. However an additional code came on in regards to the heater. As per PEP Boys mechanic shop and Auto Zone the emissions keep failing and may need a new co

2024-11-05, Engine
The contact owns a 2006 Ford Explorer. The contact stated while driving at an undisclosed speed, the engine seized. The vehicle was driven to the shoulder of the road. The contact parked the vehicle and allowed the vehicle to set for a while. The vehicle was started. The contact stated that the vehicle was driven 100 yards before the failure reoccurred. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 150,000.

2023-07-26, Power Train
THIS TRANSMISSION SHOULD BE RECALLED!!!! THE REVERSE BAND BREAKS AND IS A KNOWN ISSUE FOR THIS TRANSMISSION!! NO WARNING JUST WENT TO REVERSE AND NOTHING! UPON RESEARCH THIS HAS BEEN A KNOWN ISSUE SINCE DAY ONE!!

2023-03-31, Unknown Or Other
Transmission

2022-06-06, Electrical System
Complete failure of the powertrain electrical harness. Heat degradation to wire insulation has exposed all conductors. Several other owner operators have experienced the same issue wherein the Dealer has attempted repair of existing trouble codes, by replacing sensors, modules and components. Problems range from vehicle shut-off at speed, vehicle fires, no-start and failed PCM modules due to short to power or short to ground. Based on my findings, this specifically impacts vehicles ranging from 2006-2010, Ford Explorer or Mercury Mountaineer with the 4.0L SOHC engine.

2006 Ford Explorer questions

Does the 2006 Ford Explorer have any recalls?

Yes. NHTSA lists 1 safety recall for the 2006 Ford Explorer: Visibility:Windshield Wiper/Washer:Motor. Recall repairs are normally free at an authorized dealer.

What are the most common problems with the 2006 Ford Explorer?

Based on 630 owner complaints filed with NHTSA, the most-reported problem areas are Power Train (301), Engine And Engine Cooling (169), Engine (58).

How do I check if a recall on my 2006 Ford Explorer has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.