CarRecallWatchThe 2021 Ford E-450 has 6 safety recalls on file with NHTSA.
Owners have filed 27 complaints with NHTSA.
The most-reported problem area is Steering (11 reports).
2021 Ford E-450 recalls
Engine cover can overheat and burn occupants
Certain 2021 Ford E-350 and E-450 vehicles received an incomplete software update under an earlier recall.
Loss of Power Steering and Brake Assist Can Raise Crash Risk
Some 2021-2022 Ford E-350 and E-450 vehicles with dual rear wheels may have an inadequate connection between the power steering pressure line and the brake hydroboost unit.
Loss of Power Steering and Brake Assist Can Raise Crash Risk
Some vans with dual rear wheels have a connection between the power steering pressure line and the brake Hydroboost unit that may not be adequate.
Engine Cover Can Overheat and Burn Driver or Passenger
Mispositioned insulation on the underside of the engine cover may allow the cover to get excessively hot.
Wiring Can Rub Frame, Risking Engine Stall and Lost Braking Control
A wire harness near the rear of these vehicles can contact the frame and become damaged.
Low Rear Axle Fluid Can Cause Driveshaft Separation
Rear axle differential fluid in these vehicles may fall below the minimum level.
Most common 2021 Ford E-450 problems
Problem areas named in the 27 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Steering | 11 |
| Service Brakes, Hydraulic | 8 |
| Vehicle Speed Control | 7 |
| Engine | 6 |
| Service Brakes | 4 |
| Unknown Or Other | 4 |
| Forward Collision Avoidance | 4 |
| Structure | 2 |
| Suspension | 1 |
| Fuel/Propulsion System | 1 |
What owners report
Airbag module casing is cracked.
Engine camshaft and lifters failed. Truck is at a Ford dealer. Engine could fail in the middle of the road, causing an accident. This is our eighth vehicle with the same issue taken to a ford dealer in the past year. A little knocking noise started that quickly turned into a loud knocking/rattling noise. No lights came on the truck.
See attached document for complaint.
This is one of 4 of my 2021 ford econoline fleet vehicles purchased in 2021 that have had engine failure. I am one of many contractors in my area and others around the country who have had this issue with the same F59 engine. Ford has failed to issue a recall.
Engine Camshaft and lifters failed, unit was inspected by ford dealer and engine had to be replaced. Engine can stop working and truck could break down in the middle of the road. No warning lamps, just a loud knocking sound when brakes were applied and truck was downshifting to stop. A lot of other people that purchased these ford light duty trucks with the 7.3L engine are having the same issue.
2021 Ford E-450 questions
Does the 2021 Ford E-450 have any recalls?
Yes. NHTSA lists 6 safety recalls for the 2021 Ford E-450: Engine cover can overheat and burn occupants; Loss of Power Steering and Brake Assist Can Raise Crash Risk; Loss of Power Steering and Brake Assist Can Raise Crash Risk; Engine Cover Can Overheat and Burn Driver or Passenger; Wiring Can Rub Frame, Risking Engine Stall and Lost Braking Control. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2021 Ford E-450?
Based on 27 owner complaints filed with NHTSA, the most-reported problem areas are Steering (11), Service Brakes, Hydraulic (8), Vehicle Speed Control (7).
How do I check if a recall on my 2021 Ford E-450 has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.