2004 Ford E-450 Recalls, Problems & Safety Rating

2004 Ford E-450 recalls

Most common 2004 Ford E-450 problems

Problem areas named in the 27 complaints owners filed with NHTSA.

Problem area	Reports
Engine And Engine Cooling	10
Electrical System	6
Power Train	5
Tires	4
Equipment	3
Service Brakes	3
Visibility	2
Fuel System, Other	2
Structure	2
Fuel System, Diesel	2

What owners report

2023-06-16, Equipment
THE component system addressed, which is available for inspection, is the propane line routed through a jagged torched hole in the vehicle main frame; location is left-rear frame extension. Pictures are available. IF piping is allowed to remain, the propane line will sustain a propane leak with constant rubbing against the hole going through the frame. Our safety, and the safety of many others across the nation is at risk, specifically with the reports of motorhome fires to date. THE existing problem has not been confirmed by a dealer or independent service center at this time. THE existing problem has not been confirmed by the manufacturer, police, insurance representatives or others.

2022-02-01, Electrical System
My box truck caught on fire, fire started at the plug in receptacle that keeps the glow plug warm and spread from there. Luckily my across the street neighbor helped put out the fire temporarily with 2 of his fire extinguisher until the fire truck arrived, otherwise it would have been a major catastrophe.

2018-11-27, Tires
I WAS DRIVING MY RV DOWN THE FREEWAY WHEN THE INSIDE DUAL BLEW OUT ON THE PASSENGER SIDE OF THE VEHICLE. BEFORE THE TIRE BLEW OUT I NOTICED A VIBRATION ON THE PASSENGER SIDE OF THE RV. A FEW MOMENTS LATER THE TIRE BLEW OUT AND THE TREAD CAME OFF COMPLETELY LEAVING ONLY THE SIDE WALLS. I DO NOT REMEMBER RUNNING OVER ANY OBJECTS IN THE FREEWAY AND HAD NOT HIT ANY POT HOLES. THIS TIRE WAS THREE YEARS OLD WITH LESS THAN 5,000 MILES ON IT. I HAD CHECKED AND VERIFIED THE TIRE PRESSURE BEFORE LEAVING AND ENSURED THAT I HAD INFLATED THE TIRES TO THE RECOMMENDED TIRE PRESSURE PER THE VEHICLES OWNER MANUAL 80 PSI. THESE TIRES WERE THE DEFINITY DAKOTA LT225/75/16 TIRE. THE TIRE WAS REPLACED BY PEP

2018-02-23, Equipment
TL* THE CONTACT OWNS A 2004 FORD E-450. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V782000 (EQUIPMENT). THE MANUFACTURER WAS CONTACTED AT 1-855-262-3540 APPROXIMATELY TWO MONTHS AGO. THE CONTACT LEFT A VOICEMAIL FOR A CALL BACK, BUT DID NOT RECEIVE A RESPONSE. THE CONTACT FELT THAT A REASONABLE AMOUNT OF TIME HAD PASSED FOR THE RECALL REMEDY. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS NOT AVAILABLE.

2015-03-16, Electrical System
TL* THE CONTACT OWNS A 2004 FORD E-450. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THE VEHICLE STALLED. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. IN ADDITION, THE VEHICLE FAILED TO START INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A DEALER MULTIPLE TIMES. THE TECHNICIAN DIAGNOSED THAT THE POWER CONTROL MODULE, STARTER AND THE HOP OIL PRESSURE PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 119,000.

2004 Ford E-450 questions

Does the 2004 Ford E-450 have any recalls?

Yes. NHTSA lists 5 safety recalls for the 2004 Ford E-450: Equipment Adaptive/Mobility; Equipment Adaptive/Mobility; Electrical System:Wiring; Electrical System:Wiring; Engine And Engine Cooling. Recall repairs are normally free at an authorized dealer.

What are the most common problems with the 2004 Ford E-450?

Based on 27 owner complaints filed with NHTSA, the most-reported problem areas are Engine And Engine Cooling (10), Electrical System (6), Power Train (5).

How do I check if a recall on my 2004 Ford E-450 has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.