2022 Thor Motor Coach Windsport Recalls, Problems & Safety Rating

2022 Thor Motor Coach Windsport recalls

Most common 2022 Thor Motor Coach Windsport problems

Problem areas named in the 5 complaints owners filed with NHTSA.

Problem area	Reports
Unknown Or Other	3
Structure	2
Visibility/Wiper	1
Equipment	1

What owners report

2026-06-09, Unknown Or Other
I’m concerned about the bbq propane compartment getting hairline cracks and the brass shut off valve that’s made of brass and dropping down to the road and getting road rash till it grinds through the shut off valve. I just read on a Thor Facebook forum that this happened to a 2016 Thor Windsport 34P. I have the pictures he posted. I asked AI Gemini, apparently this is a known and well documented safety issue. I can forward the link to the AI report. Will link here if this works. The pictures are mine (intact) and the other two are his 2016 motorhome. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2024-11-25, Structure
While driving on a crowded freeway a wooden structure fell from the ceiling of my motorhome and landed on the dashboard inches from my steering wheel. If it had hit my steering wheel or my hands, I would have been involved in a multiple vehicle collision. Thank God, I was able to safely pull over to the shoulder to check for damage. The beam was too heavy for me to move it. I drove it to a Camping World repair facility. The repair technician inspected the damage. He told me the support structure fell because it was held up by only one screw. Please note the comments for Job#4 in the repair invoice I hope to attach. I tried to upload some photos of the fallen structure, but I couldn't upload

2024-10-21, Structure
The contact owns a 2022 Thor Motor Coach Windsport RV built on a 2020 Ford F-53 chassis. The contact stated that while driving at 65 MPH, a wooden beam used to deflect airflow from the outer venting fell from the ceiling of the RV. The heavy beam fell inches away from the contact's hands that were on the steering wheel. The contact pulled over after the failure but could not move the beam due to the weight. Despite the failure, the contact was able to drive the vehicle to the RV dealer where it remained. The manufacturer was notified of the failure but offered no assistance. The beam was reinstalled, and the RV was repaired. The contact expressed concerns that the failure might reoccur, and

2024-05-27, Unknown Or Other
The propane heater on our motorhome has been cycling on the high limit switch since new. This is due to insufficient airflow across the heat exchanger. It is also the source of intermittent carbon monoxide alarms being activated. We have had this unsuccessfully repaired under warranty. The cycling continues. If other units of this model series were built the same way, I suspect this is a problem common to all. This also creates a fire risk should the high limit switch be operated enough times for it to fail. I am now using an electric heater, but this requires I be hooked up to electric service.

2024-03-09, Unknown Or Other
Main propane heater in my Thor Windsport 29M motorhome was coming on and goings on off before the desired temperature was reached. I realized it was cycling on the high limit switch, which is.generally caused by insufficient air flow over the heat exchanger. Took it in for warranty service which identified the cause as a kinked heater hose, which had to have been done at the factory during installation. Had the high limit switch failed, the motorhome would have been lost to a fire. Due to the high heat caused by the kinked duct, the blower wheel had partially melted.

2022 Thor Motor Coach Windsport questions

Does the 2022 Thor Motor Coach Windsport have any recalls?

Yes. NHTSA lists 1 safety recall for the 2022 Thor Motor Coach Windsport: Rear ladder may be on wrong side and break during use. Recall repairs are normally free at an authorized dealer.

What are the most common problems with the 2022 Thor Motor Coach Windsport?

Based on 5 owner complaints filed with NHTSA, the most-reported problem areas are Unknown Or Other (3), Structure (2), Visibility/Wiper (1).

How do I check if a recall on my 2022 Thor Motor Coach Windsport has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.