CarRecallWatchThe 2016 Thor Motor Coach Windsport has 8 safety recalls on file with NHTSA.
Owners have filed 9 complaints with NHTSA.
The most-reported problem area is Visibility/Wiper (5 reports).
2016 Thor Motor Coach Windsport recalls
Fire extinguisher may clog or fail to discharge in a fire
Some fire extinguishers installed in these recreational vehicles may become clogged, so they may not discharge as expected, or may require excessive force to operate.
Windshield Wipers May Fail, Reducing Driver Visibility
Certain Thor Motor Coach motorhomes from model years 2014 to 2016 may have windshield wiper systems that were installed or secured incorrectly.
Windshield wipers may fail, reducing driver visibility
Certain 2014-2015 Thor Motor Coach motorhomes may have windshield wiper systems that were improperly installed and not properly secured.
Exhaust Heat Can Melt Storage Compartment, Raising Fire Risk
On certain motor homes, the vehicle exhaust is located near a storage compartment.
Motorhome entry steps may detach and cause falls
Certain motorhomes built with Lippert Coachstep electric entry and exit steps may have a bolt that attaches the steps' fan gear assembly.
Motorhome Can Shift Out of Park Without Brakes, Risking Crash
The automatic transmission shift cable bracket may be incorrect, and the shift cable may be improperly adjusted.
Parking Brake May Fail to Hold, Risking Rollaway or Fire
Certain 2016 motorhomes built between July 31 and September 9, 2015 may have a parking brake actuator that is out of calibration.
Co-Pilot Seat May Loosen in a Crash, Raising Injury Risk
Certain 2016 motorhomes built between March 10 and March 24, 2015 may have their co-pilot seats attached to a floor area that is not properly reinforced.
Most common 2016 Thor Motor Coach Windsport problems
Problem areas named in the 9 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Visibility/Wiper | 5 |
| Power Train | 2 |
| Suspension | 2 |
| Equipment | 1 |
| Equipment Adaptive/Mobility | 1 |
| Structure | 1 |
| Unknown Or Other | 1 |
What owners report
The windshield wipers get out of sync and collide, usually it ends up with the passenger wiper stuck down behind the driver's wiper and they both stop with no way to clear the rain from the windshield. There have been recalls issued for my model & year of RV but THOR says they don't apply to my RV. This has happened several times. My "solution" is to remove the passenger wiper.
This is a 2016 THOR Windsport 29M with 9400 miles. Missing parts/damaged parts were discovered during normal maintenance check by certified ASE mechanic. RT rear anti sway bar retainer (#5486), (2) HB3 Bolts and (1) welded flange nuts are missing from motorhome. Additional inspection revels top welded flange nut missing due to weld not holding or never welded correctly. Bottom flange nut internal threads are galled and will not accept a correct M10 bolt.
While driving during a rain storm both wipers stopped working. Drivers wiper fell to drivers side resting on side rear view mirror and passengers fell down front of the RV. Pulled over and stopped until rain stopped. After looking in engine compartment the hardware that connects both wiper arms to the motor broke off from where the wipers arms connect. No indication of failure until both arms just broke off. Looks like they broke because of stress moving the wipers across windshield. Not sure if poor design of poor metal used.
MOTORHOME CAME OUT OF PARK AND BEGAN TO ROLL DOWN PRIVATE DRIVEWAY UNEXPECTEDLY AFTER THE SHIFT LEVER WAS PULLED DOWN WITHOUT THE KEY IN THE IGNITION OR THE BRAKES APPLIED. OWNER WAS ABLE TO GET INSIDE AND APPLY BRAKES PREVENTING ANY DAMAGE TO PROPERTY OR LIFE.
WHEN WIPER BLADES ARE TURNED ON IN THE HIGHWAY, THE WIPER GO DOWN TOO FAR AND GET STUCK BELOW THE WINDSHIELD. UNABLE TO USE THE WIPERS.
2016 Thor Motor Coach Windsport questions
Does the 2016 Thor Motor Coach Windsport have any recalls?
Yes. NHTSA lists 8 safety recalls for the 2016 Thor Motor Coach Windsport: Fire extinguisher may clog or fail to discharge in a fire; Windshield Wipers May Fail, Reducing Driver Visibility; Windshield wipers may fail, reducing driver visibility; Exhaust Heat Can Melt Storage Compartment, Raising Fire Risk; Motorhome entry steps may detach and cause falls. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2016 Thor Motor Coach Windsport?
Based on 9 owner complaints filed with NHTSA, the most-reported problem areas are Visibility/Wiper (5), Power Train (2), Suspension (2).
How do I check if a recall on my 2016 Thor Motor Coach Windsport has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.