CarRecallWatchThe 2016 Hyundai Tucson has 5 safety recalls on file with NHTSA.
Owners have filed 1,626 complaints with NHTSA, including 14 crashes, 26 fires, 7 injuries.
The most-reported problem area is Power Train (519 reports).
NHTSA rates it up to 5 stars overall for crash safety, depending on the version.
2016 Hyundai Tucson recalls
Brake Control Module Can Short and Cause Engine Fire
The anti-lock brake hydraulic electronic control unit (HECU) in these vehicles can corrode internally.
Trailer Brake Lights May Stay On, Confusing Other Drivers
Certain Hyundai vehicles with an accessory trailer hitch wiring harness may have a malfunction in the tow hitch module.
Tucson May Stop Moving in Traffic, Raising Crash Risk
Certain 2016 Tucson vehicles built between May 2015 and May 2016 with a 7-speed dual clutch automatic transmission may fail to move when the accelerator pedal is pressed, particularly under certain driving conditions and high temperatures.
Hood may open while driving, raising crash risk
Certain 2016 Tucson vehicles built between May 2015 and March 2016 have a hood latch problem.
Trailer turn signals may fail to flash, raising crash risk
On certain 2016 Tucson SUVs equipped with an accessory trailer hitch harness, the trailer turn signal lights can behave incorrectly.
Most common 2016 Hyundai Tucson problems
Problem areas named in the 1,626 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Power Train | 519 |
| Engine | 424 |
| Unknown Or Other | 264 |
| Structure | 227 |
| Electrical System | 217 |
| Latches/Locks/Linkages | 158 |
| Vehicle Speed Control | 112 |
| Fuel/Propulsion System | 55 |
| Service Brakes | 35 |
| Exterior Lighting | 30 |
What owners report
Description of Defect: Progressive, complete failure of all four (4) power window regulators on a low-mileage 2016 Hyundai Tucson (~29,848 miles). Three windows failed in rapid succession, followed by the fourth, rendering all power windows completely inoperable. Safety Hazard: The inability to operate any window creates a dangerous safety risk during driving and emergency situations, including restricted egress during a crash, lack of cabin ventilation in high heat, and inability to clear windshield/window fogging or signal outside the vehicle. Manufacturer Response: Inspected by Hyundai dealer (Repair Order #348315). Hyundai Corporate (Case #42475291) acknowledged the issue and offered a
When I try accelerate from a stopped position vehicles acts as if it doesnât want to move and you need your acceleration when crossing traffic or turning onto a busy street I just got the car from carmax 6 days ago so I will take it to their service department and try to find out more
Excessive oil consumption. Mileage is 116.7K miles. Over 4 quarts used in approximately 3,500 miles. Car went into "limp" mode with no power. Top speed on level ground was 45 mph, on a hill 25 mph. Had to pull over to the side of the road so that other cars could pass. Drove to mechanic who saw about 1 quart remained in the car. Oil light didn't go on. Service engine light flashed when the car went into "limp" mode.
The contact owns a 2016 Hyundai Tucson. The contact stated that while driving at 15 MPH, the vehicle failed to accelerate when the accelerator pedal was pressed and released repeatedly at 1,200 RPM. The transmission warning light illuminated. Additionally, the rear driver's and rear passenger's side doors failed to open. The dealer was notified of the failure but informed the contact that there was no recall associated with the VIN. The contact associated the failure with NHTSA Campaign Number: 16V628000 (Power Train, Electrical System); however, the VIN was not included in the recall. The manufacturer was notified of the failure by email. The failure mileage was approximately 95,000.
Repeated Window Regulator Failures on 2016 Hyundai Tucson To Whom It May Concern, I am the owner of a 2016 Hyundai Tucson with approximately 54,000 miles. I am writing to request goodwill assistance regarding repeated failures of the vehicle's power window regulators. Over the past year and a half, all four power window regulators have failed, one after another. In each case, the failure appears to be related to the plastic wheel pulley/drum gear spool component within the regulator assembly. The failures have occurred at relatively low mileage and under normal vehicle use. The repair cost quoted by my Hyundai dealer is approximately $500 per window, resulting in a substantial financial bur
2016 Hyundai Tucson safety rating
| Version | Overall | Frontal | Side | Rollover |
|---|---|---|---|---|
| 2016 Hyundai Tucson SUV AWD | ★★★★★ 5-star | 5 | 5 | 4 (16.2% rollover risk) |
| 2016 Hyundai Tucson SUV FWD | ★★★★★ 5-star | 5 | 5 | 4 (15.5% rollover risk) |
2016 Hyundai Tucson questions
Does the 2016 Hyundai Tucson have any recalls?
Yes. NHTSA lists 5 safety recalls for the 2016 Hyundai Tucson: Brake Control Module Can Short and Cause Engine Fire; Trailer Brake Lights May Stay On, Confusing Other Drivers; Tucson May Stop Moving in Traffic, Raising Crash Risk; Hood may open while driving, raising crash risk; Trailer turn signals may fail to flash, raising crash risk. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2016 Hyundai Tucson?
Based on 1,626 owner complaints filed with NHTSA, the most-reported problem areas are Power Train (519), Engine (424), Unknown Or Other (264).
How safe is the 2016 Hyundai Tucson?
NHTSA's 5-Star Safety Ratings program gives the 2016 Hyundai Tucson up to 5 out of 5 stars overall; ratings vary by version, see the table above.
How do I check if a recall on my 2016 Hyundai Tucson has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.