2020 Hyundai Tucson Recalls, Problems & Safety Rating

2020 Hyundai Tucson recalls

Most common 2020 Hyundai Tucson problems

Problem areas named in the 179 complaints owners filed with NHTSA.

Problem area	Reports
Engine	73
Unknown Or Other	28
Service Brakes	26
Electrical System	19
Service Brakes, Hydraulic	17
Forward Collision Avoidance	13
Power Train	9
Back Over Prevention	7
Lane Departure	7
Air Bags	7

What owners report

2026-10-15, Forward Collision Avoidance
The contact owns a 2020 Hyundai Tucson. The contact stated that upon starting the vehicle, the check engine, master general, and forward collision warning lights were illuminated. The vehicle was taken to the dealer, where it was diagnosed, and the contact was advised that the multifunction camera had failed and needed to be replaced. The manufacturer was notified of the failure. The failure mileage was 44,000.

2026-09-25, Engine
On XXX, while driving at freeway speed in [XXX] with my [XXX] son in the back seat, the engine of my 2020 Hyundai Tucson (2.4L Theta II GDI, approx. 99,108 miles) seized suddenly and without warning. I lost all motive power in moving traffic and coasted to the shoulder, where my son and I sat stranded for 30 minutes with smoke and a burning smell coming from the engine while waiting for a tow. No warning lamps or messages appeared before the failure. COMPONENT FAILED: Engine. Tustin Hyundai ([XXX]) diagnosed the failure on RO XXX: engine seized; connecting rod pierced through the bottom of the engine block due to internal catastrophic failure at the crankshaft/bearings; starter had a burnt

2026-09-18, Engine
Engine has defect that causes oil to heat at an unusual levels there for damaging other vehicle components such as The exhaust system parts clogging up and Triggering check engine warning lights for emissions.

2026-08-20, Engine
The contact owns a 2020 Hyundai Tucson. The contact stated that while the vehicle was receiving a routine oil change, the contact was informed that the oil pan was empty. The contact was advised to take the vehicle to the dealer. The contact was informed about a possible oil consumption test. The contact was informed that there was carbon blowing out of the vehicle. The contact stated that three months later, the oil pan was empty. The vehicle was taken back to the dealer, and engine oil was added; however, the failure reoccurred. The vehicle was taken back to the dealer where the contact was informed that the engine needed to be replaced. The vehicle was repaired. The contact stated that wh

2026-08-09, Fuel/Propulsion System
Dealer completed update 9C2 Theta 2 emissions update. After update, the car sputters slightly and increased noise is heard from the tailpipe. Customer returned to dealer after driving the car in different temps and noted the above complaint. Dealer verified the complaint but continues to take no responsibility for the fault on the repair receipt by writing condition is “normal” and recommending “customer to allow vehicle to properly warm up for one to three minutes prior to driving.” The last line of the service record indicates “no problem found at this time.” A template letter from Hyundai was attached to the repair record. Hyundai may be instructing dealers to not document pro

2020 Hyundai Tucson questions

Does the 2020 Hyundai Tucson have any recalls?

Yes. NHTSA lists 1 safety recall for the 2020 Hyundai Tucson: Brake Control Module Can Short and Cause Engine Fire. Recall repairs are normally free at an authorized dealer.

What are the most common problems with the 2020 Hyundai Tucson?

Based on 179 owner complaints filed with NHTSA, the most-reported problem areas are Engine (73), Unknown Or Other (28), Service Brakes (26).

How do I check if a recall on my 2020 Hyundai Tucson has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.