CarRecallWatchThe 2020 Ford Fusion has 3 safety recalls on file with NHTSA.
Owners have filed 185 complaints with NHTSA, including 10 crashes, 3 fires, 5 injuries.
The most-reported problem area is Power Train (67 reports).
2020 Ford Fusion recalls
Engine Block Heater May Crack and Cause Fire Risk
The engine block heater can crack and develop a coolant leak.
Rearview Camera May Show Blank or Stuck Image
A software error can cause the rearview camera to display a blank image, or to keep showing the camera image after the vehicle has left reverse.
Battery Control Module Can Fail, Causing Power Loss or Fire
The battery energy control module (BECM) in certain plug-in hybrid vehicles may be damaged by excessive voltage and current flow.
Most common 2020 Ford Fusion problems
Problem areas named in the 185 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Power Train | 67 |
| Engine | 53 |
| Electrical System | 38 |
| Unknown Or Other | 28 |
| Steering | 12 |
| Fuel/Propulsion System | 12 |
| Forward Collision Avoidance | 11 |
| Service Brakes | 10 |
| Engine And Engine Cooling | 7 |
| Structure | 5 |
What owners report
COMPONENT/SYSTEM: Gasoline vapor entering the occupied passenger cabin through the HVAC vents during and after rain with the A/C or heat on. Root cause unidentified, not because it cannot be found, but because Ford Motor Company has not once tested the vehicle under the condition in which the defect occurs, and has refused in writing to assign an engineer who would. Suspected fuel system / evaporative emissions / cowl-to-HVAC intake pathway. Vehicle available to NHTSA for inspection on request. SAFETY RISK: The driver and passengers breathe gasoline vapor inside a closed, moving vehicle. Fuel vapor in an occupied cabin is an inhalation hazard and an ignition hazard. The owner drives with th
Our 2020 Ford Fusion automatically shifts back into Park and displays the "Shift Sys Fault" error message, the primary culprit is a broken transmission shift cable bushing. Vehicle may be in gear and unable to stop itself from rolling on an incline unless parking brake is applied.
The contact's brother owns a 2020 Ford Fusion. The contact stated that while the owner was driving 35 MPH, the engine overheated and there was misfire coming from the engine. The check engine warning light illuminated, and there was fluid leaking into the engine. An independent mechanic was contacted by phone. The vehicle was taken to the independent mechanic and was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The contact was informed that the failure was a known failure with the vehicle. In addition, the contact was informed that the failure was due to the manufacturing design of the engine. The manufacturer was contacted by phone and a cas
2020 Fusion SEL with 41,000 miles. While driving at 65 mph with adaptive cruise control engaged, the vehicle suddenly jerked on two separate occasions during a three-hour drive.
I recently acquired this vehicle from a dealer after the previous owner traded it in and after reviewing the Carfax I did some deeper digging into this vehicle and discovered that there are 3 recalls that have not been serviced. I am hoping that there wasn't any secondary damage due to the recalled items as I haven't noticed anything necessarily wrong with the car but I figured I'd take it in to be safe. I also want a quote for a transmission drain and fill, NOT A FLUSH. The transmission is shifting fine, I just am looking to get it done as preventative maintenance and for peace of mind. The recall repairs are noted in the PDF attached below.
2020 Ford Fusion questions
Does the 2020 Ford Fusion have any recalls?
Yes. NHTSA lists 3 safety recalls for the 2020 Ford Fusion: Engine Block Heater May Crack and Cause Fire Risk; Rearview Camera May Show Blank or Stuck Image; Battery Control Module Can Fail, Causing Power Loss or Fire. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2020 Ford Fusion?
Based on 185 owner complaints filed with NHTSA, the most-reported problem areas are Power Train (67), Engine (53), Electrical System (38).
How do I check if a recall on my 2020 Ford Fusion has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.