CarRecallWatchThe 2008 BMW R1200 RT has 5 safety recalls on file with NHTSA.
Owners have filed 32 complaints with NHTSA, including 1 fire, 1 injury.
The most-reported problem area is Fuel/Propulsion System (15 reports).
2008 BMW R1200 RT recalls
Fuel Pump Flange May Crack, Causing Leaks and Fire Risk
The fuel pump flange on certain BMW motorcycles that were previously repaired under recall 13V-617 with the support ring remedy may crack.
Rear Wheel Can Loosen and Cause Loss of Control
The rear wheel mounting flange, which is aluminum on the affected motorcycles, may crack if the rear wheel mounting bolts are overtightened.
Most common 2008 BMW R1200 RT problems
Problem areas named in the 32 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Fuel/Propulsion System | 15 |
| Service Brakes | 6 |
| Power Train | 4 |
| Fuel System, Gasoline | 3 |
| Service Brakes, Hydraulic | 1 |
| Engine And Engine Cooling | 1 |
| Wheels | 1 |
| Electrical System | 1 |
What owners report
The bike is a 2008 BMW R1200RT. The throttle bodies for each cylinder has a plastic cam that is the point of attachment for the throttle cable. That plastic cam broke and completely detached from the bike. I was accelerating to merge into traffic on Interstate 64E at Corydon, IN. Once established in the right lane, the bike suddenly lost power and slowed rapidly while I was approached from the rear by a tractor trailer that had to apply brakes and continuously sounded his horn while abruptly maneuvering to the left lane to avoid me while I was attempting to assess what had just happened. This is a critical safety component and its failure has been documented countless number of times on var
My forth vehicle with throttle body cams that are cracked and broken on both sides. No symptoms or warning lights of a problem that could have lead to a catastrophic failure, total engine propulsion failure, breakdown. My safety and others were in danger of injury or death. Dealer has confirmed and repaired all vehicles.
This is a two-cylinder engine with an independent throttle body for each cylinder. The throttle is actuated by a cable and pulley which rotate the throttle plate on a shaft. The pulley is attached to the shaft with molded plastic. Upon inspection during service, both plastic moldings (both cylinders) were discovered to be cracked and near failure. Failure of this part will cause that cylinder to go to idle power. If the vehicle is in motion, there will be a sudden loss of power, and high vibration until the throttle is closed. Until repair, the motorcycle will be inoperable. This has become a known defect with this series of motorcycles. I repaired mine using an aftermarket aluminum part
THIS SERIES OF MOTORCYCLES HAS A COMMON PROBLEM WITH CRACKS IN THE THROTTLE PULLEYS ON THE THROTTLE BODY. FAILURE OF THIS PLASTIC PART WILL RESULT IN INSTANT LOSS OF POWER. I HAVE BEEN READING ABOUT THIS PROBLEM, AND DECIDED TO INSPECT THE TWO THROTTLE BODIES ON MY MOTORCYCLE AS A PRECAUTION. BOTH OF MINE WERE CRACKED. ONE OF THE PULLEYS HAS THREE CRACKS IN IT, AND WOULD LIKELY HAVE FAILED WITHIN A SHORT TIME. SEE PHOTOS INCLUDED WITH THIS REPORT.
ABS PUMP MOTOR IS FAILING ON MANY OF THE SAME MODEL BIKES AND SOME OTHER 2006-2008 MODEL BMW BIKES WITH LOW MILEAGE, BECAUSE THE BRUSH HOLDERS IN THE ABS ELECTRICAL MOTOR ARE TOO TIGHT AND BRUSHES GET STUCK IN THEM - BAD DESIGN OF THE ABS PUMP MOTOR. BMW WILL ASK YOU LOADS OF MONIES FOR THE REPLACEMENT OF THE PUMP, EVEN THO THEY ARE FULLY AWARE IT'S A PROBLEM WITH MANY OF THE BIKES.
2008 BMW R1200 RT questions
Does the 2008 BMW R1200 RT have any recalls?
Yes. NHTSA lists 5 safety recalls for the 2008 BMW R1200 RT: Fuel Pump Flange May Crack, Causing Leaks and Fire Risk; Rear Wheel Can Loosen and Cause Loss of Control; Fuel System, Gasoline:Delivery:Fuel Pump; Service Brakes, Hydraulic; Service Brakes, Hydraulic. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2008 BMW R1200 RT?
Based on 32 owner complaints filed with NHTSA, the most-reported problem areas are Fuel/Propulsion System (15), Service Brakes (6), Power Train (4).
How do I check if a recall on my 2008 BMW R1200 RT has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.