CarRecallWatchThe 2007 Volvo S80 has 5 safety recalls on file with NHTSA.
Owners have filed 24 complaints with NHTSA.
The most-reported problem area is Structure (6 reports).
2007 Volvo S80 recalls
Front Seat Belt Cable May Fail, Leaving Occupants Unsecured
The flexible steel cable that connects the front outboard seat belts to the vehicle can fatigue over time.
Most common 2007 Volvo S80 problems
Problem areas named in the 24 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Structure | 6 |
| Electrical System | 4 |
| Engine | 4 |
| Steering | 4 |
| Unknown Or Other | 3 |
| Visibility | 2 |
| Visibility/Wiper | 2 |
| Exterior Lighting | 2 |
| Seat Belts | 1 |
| Service Brakes, Hydraulic | 1 |
What owners report
The contact owns a 2007 Volvo S80. The contact stated that while operating the vehicle during a rainstorm; rainwater leaked into the vehicle from the top section of the driver's side of the windshield, creating a visibility hazard for the driver. The cause of the failure was not determined. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not contacted regarding the failure. The failure mileage was 150,000.
These generation of Volvo p3 platform cars had a defective windshield seal that was not the best from the factory. Many cars of this generation (S60, S80, XC90, etc) have had the seals break, causing extreme water leakage as mine has had. And the possibility of the windshield falling out. Mine is bad enough that pushing it lightly from the inside to create a significant gap in the window and the frame of the A pillar. There are many forums and reports of this exact problem and Volvo has yet to voluntarily recall these cars. Many people have reported it to many dealers, but all say they cant replace them. This problem definitely puts the driver and other people in the cabin in danger. And no
Warning light on dashboard indicated right front headlamp out. Repair shop removed and replaced original component with new component. Internal inspection of light assembly revealed missing insulation(photos attached) on wiring harness causing a short circuit which also ruined the headlight igniter and control module. Shop stated that this issue is NOT uncommon with Volvo lighting systems. The current concern is the same condition is present in the left(driver) headlight and could cause a short and fire within the headlight assembly. Correspondence with Volvo resulted in no resolution of the issue and lack of concern for the reliability of installed components or possible safety conc
EXCESSIVE RUST IS FORMING ON MY FRONT SUBFRAME AND IN SOME PLACES HAS RUSTED COMPLETELY THROUGH. SMALL PERFERATIONS WERE NOTICED AT REPAIR FACILITY AND I WAS TOLD THAT IT WILL NEED TO BE REPLACED. IT CANNOT BE WELDED/REPAIRED. THIS IS A KNOWN PROBLEM WITH THE 2007-2010 VOLVO S80 V8 WHICH VOLVO REFUSES TO RECALL AND WILL BE AN EXTREMELY COSTLY REPAIR. IT ALSO MAKES THE CAR UNSAFE TO DRIVE SHOULD THE REPAIR NOT BE MADE.
EXCESSIVE RUST IS FORMING ON MY FRONT SUBFRAME AND IN SOME PLACES HAS RUSTED COMPLETELY THROUGH. I HAVE A SILVER DOLLAR SIZED HOLE THROUGH IT AND IT WILL NEED TO BE REPLACED. THIS IS A KNOWN PROBLEM WITH THE 2007-2010 VOLVO S80 V8 WHICH VOLVO REFUSES TO RECALL AND WILL BE AN EXTREMELY COSTLY REPAIR. IT ALSO MAKES THE CAR UNSAFE TO DRIVE AND I COULD ALSO NOT PASS INSPECTION IN PA FOR THIS KIND OF DAMAGE.
2007 Volvo S80 questions
Does the 2007 Volvo S80 have any recalls?
Yes. NHTSA lists 5 safety recalls for the 2007 Volvo S80: Front Seat Belt Cable May Fail, Leaving Occupants Unsecured; Steering:Hydraulic Power Assist:Hose, Piping, And Connections; Equipment:Electrical:Navigational System(Global Positioning System); Tires:Pressure Monitoring And Regulating Systems; Electrical System:Software. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2007 Volvo S80?
Based on 24 owner complaints filed with NHTSA, the most-reported problem areas are Structure (6), Electrical System (4), Engine (4).
How do I check if a recall on my 2007 Volvo S80 has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.