2023 Toyota 4 Runner Recalls, Problems & Safety Rating

2023 Toyota 4 Runner recalls

Most common 2023 Toyota 4 Runner problems

Problem areas named in the 33 complaints owners filed with NHTSA.

Problem area	Reports
Unknown Or Other	12
Tires	4
Exterior Lighting	3
Forward Collision Avoidance	3
Steering	3
Suspension	3
Back Over Prevention	2
Seat Belts	2
Service Brakes	2
Air Bags	2

What owners report

2026-10-14, Suspension
Vehicle Component: Solid Rear Axle Assembly / Rear Suspension GeometryDefect Summary: The vehicle exhibits a factory manufacturing defect causing severe rear axle misalignment. At approximately 350 miles from new, an official dealership Hunter alignment report documented out-of-spec rear alignment parameters (-0.16° rear total toe) on a non-adjustable, factory solid rear axle assembly. Safety Risk & Impact: A misaligned solid rear axle compromises vehicle stability, introduces rear thrust angle deviation, and impairs predictable vehicle tracking and emergency evasive handling at highway speeds. Because a solid rear axle has no factory adjustment points, this indicates a bent or improperly

2026-09-04, Latches/Locks/Linkages
The contact owns a 2023 Toyota 4Runner. The contact stated that the driver's side door failed to lock using the key fob or the buttons on the door. The doors had to be manually locked and unlocked. The vehicle was taken to the dealer, where it was confirmed to be a known issue, and the locks were replaced. Shortly after the vehicle was repaired, the failure reoccurred. The vehicle was taken to the dealer, and the failure was confirmed; however, the warranty coverage only provided a repair for the driver's side door. The failure had occurred on the passenger door and the rear driver’s side door, and the repairs were not covered under recall or warranty. The vehicle was not repaired. The man

2026-08-25, Tires
Purchased size 265/70R17 tires (Michelin Defender LTX M/S2) exhibiting severe highway vibration immediately post-installation. The vibration persisted continuously for two years across every rotation, posing serious handling and steering risks. For two years, local shop staff gaslit the customer, claiming an "out-of-round" tire or casing defect was impossible to avoid warranty obligations. During a visit in front of store management, staff repeated the claim in front of management. The customer then presented real-time technical data from Google on the spot, forcing staff to admit casing defects happen. Despite this, management cleared the driver to leave, assuring the vehicle was safe to

2026-05-21, Service Brakes
New, strange noise started in Dec'25 (41K miles; 2yrs 9 months). No warning lights. Diagnosed as failed brake accumulator (first at an independent shop, later at the dealer). Apparently the accumulator is part of the full master cylinder assembly which must be replaced. Toyota has quoted $3,200 to complete this repair and is telling me it must be out of pocket.

2026-03-03, Steering
I was driving the vehicle and suddenly the steering wheel started to getting hard to turn it and the dash board doesn’t show any failure I went right away to dealership close by they inspected the vehicle they states there is a power steering failure but the car never showed any failure on dashboard or safety system

2023 Toyota 4 Runner questions

Does the 2023 Toyota 4 Runner have any recalls?

Yes. NHTSA lists 1 safety recall for the 2023 Toyota 4 Runner: Incorrect Load Limit Label Could Lead to Overloading and Crash Risk. Recall repairs are normally free at an authorized dealer.

What are the most common problems with the 2023 Toyota 4 Runner?

Based on 33 owner complaints filed with NHTSA, the most-reported problem areas are Unknown Or Other (12), Tires (4), Exterior Lighting (3).

How do I check if a recall on my 2023 Toyota 4 Runner has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.