2002 Mercedes-Benz 320 Recalls, Problems & Safety Rating

2002 Mercedes-Benz 320 recalls

No safety recalls on file for the 2002 Mercedes-Benz 320.

Most common 2002 Mercedes-Benz 320 problems

Problem areas named in the 11 complaints owners filed with NHTSA.

Problem area	Reports
Electrical System	4
Seats	3
Visibility	3
Steering	3
Tires	2
Engine And Engine Cooling	2
Structure	2
Fuel System, Gasoline	2
Engine	1

What owners report

2014-05-05, Fuel System, Gasoline
WITHOUT NOTICABLE WARNING, THE SENSOR PANEL FLASH FOR A SECOND, THEN THE CAR CAME TO A SUDDEN AND COMPLETE STOP, THE ENGINE SHUT OFF IN THE MIDDLE OF BUSY FREEWAY. AFTER A FEW ATTEMPTS, THE VEHICLE RESTARTED AND WAS DRIVEN TO THE SIDE OF ROAD. AFTER TOWING TO AN EXPERIENCED MERCEDES REPAIR SHOP, THEY CONCLUDED THE VEHICLE EXPERIENCED A COMPLETE POWER SHUTDOWN BY DESIGN TO PROTECT THE ELECTRICAL SYSTEM BECAUSE THE ALTERNATOR WAS OVERCHARGIJNG. THE INCIDENT WAS REPORTED TO MERCEDES -BENZ AT MONTVALE, NJ, THEY DID NOT WANT TO DO ANY INVESTIGATION OR FOLLOW-UP. SIMILAR INCIDENT ON 12/31/2012 ON THE SAME MODEL, SAME YEAR WAS REPORTED ON YOUR WEBSITE DATED MARCH 17, 2013 BY ANOTHER DRIVER .

2013-05-19, Seats
THE PASSENGER SEAT POWER ADJUSTMENT MODULE SHORTED, DRAINING THE BATTERY AND CAUSING A NO-START CONDITION. WHILE THIS DID NOT OCCUR WHILE STUCK IN TRAFFIC, IT EASILY COULD HAVE, CAUSING A SERIOUS HAZARD FOR MYSELF, ANY PASSENGER OR ANOTHER VEHICLE. THE SEAT MODULE HAD TO BE DISCONNECTED SO THERE IS NO LONGER THE ABILITY TO ADJUST THE SEAT AND OBTAIN PROPER CLEARANCE FROM THE AIRBAG OR TO PROPERLY ADJUST THE SEAT AND ALLOW A CHILD SEAT TO FIT AS DESIGNED IN THE REAR SEAT. *TR

2009-03-24, Steering
TL*THE CONTACT OWNS A 2002 MERCEDES BENZ 320. IN NOVEMBER OF 2008, THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 03V121000 (STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS) AND TOOK HER VEHICLE TO THE DEALER. THE DEALER INSTALLED A NEW HOSE CLAMP ON THE POWER STEERING HOSE TO THE POWER STEERING COOLER. ONE MONTH LATER, SHE HEARD A LOUD NOISE. SHE WENT TO THE NEAREST MECHANIC AND WAS INFORMED THAT THE POWER STEERING FLUID WAS COMPLETELY DRY AND THE POWER STEERING PUMP WAS DAMAGED. ONE WEEK LATER, THE CONTACT RECEIVED A SECOND RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 08V465000 (STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS), WHICH REQUES

2008-10-15, Structure
TL*THE CONTACT OWNS A 2002 MERCEDES BENZ ML 320. WHILE PARKED IN THE CONTACT'S DRIVEWAY, AFTER SEVERE RAIN, WATER LEAKED APPROXIMATELY FOUR INCHES ABOVE THE OPENINGS OF THE PASSENGER AND DRIVER'S SIDE REAR INTERIOR DOORS. IN ADDITION, THERE WAS POWER STEERING FLUID LEAKAGE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY STATED THAT THE FAILURE WAS RELATED TO THE POWER STEERING HOSE. THE TECHNICIAN ADDED ADDITIONAL POWER STEERING FLUID INTO THE RESERVOIR, WHICH WAS EXTREMELY LOW. THE CONTACT STATED THAT THE POWERING STEERING FLUID LEVEL WAS BEING MONITORED IN THE VEHICLE. THE VEHICLE HAS NOT BEEN REPAIRED FOR THE FAILURES. THE FAILURE AND CURRENT MILEAGES WERE 79,000.

2005-05-03, Engine And Engine Cooling
THE CONSUMER STATED THE VEHICLE BURNED AN EXCESSIVE AMOUNT OIL. *JB

2002 Mercedes-Benz 320 questions

Does the 2002 Mercedes-Benz 320 have any recalls?

No. NHTSA has no safety recalls on file for the 2002 Mercedes-Benz 320 at this time.

What are the most common problems with the 2002 Mercedes-Benz 320?

Based on 11 owner complaints filed with NHTSA, the most-reported problem areas are Electrical System (4), Seats (3), Visibility (3).

How do I check if a recall on my 2002 Mercedes-Benz 320 has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.