CarRecallWatchThe 2020 Ford F-550 has 2 safety recalls on file with NHTSA.
Owners have filed 17 complaints with NHTSA, including 1 fire.
The most-reported problem area is Fuel System, Diesel (6 reports).
2020 Ford F-550 recalls
Low Rear Axle Fluid Can Cause Driveshaft Separation
Rear axle differential fluid in these vehicles may fall below the minimum level.
Seatback May Not Hold in a Crash, Raising Injury Risk
Certain manual front and rear seats in these vehicles may be missing a third pawl in the recliner mechanism, which is needed to keep the seatback strong.
Most common 2020 Ford F-550 problems
Problem areas named in the 17 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Fuel System, Diesel | 6 |
| Power Train | 3 |
| Suspension | 3 |
| Structure | 3 |
| Engine | 3 |
| Fuel/Propulsion System | 2 |
| Service Brakes | 1 |
| Visibility | 1 |
| Unknown Or Other | 1 |
| Electrical System | 1 |
What owners report
The contact owns a 2020 Ford F-550. The contact stated that while the vehicle was parked, it was discovered that there was metal deposits inside the system causing the fuel pump failure. The contact associated the failure with NHTSA Campaign Number: 24V957000 (Fuel System, Diesel). The dealer was contacted but failed to retrieve the correct diagnostic trouble codes related to the recall. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 150,000.
I had my truck serviced, engine oil and fuel filters replaced, I picked up truck and while driving home, engine loss of power came on screen, truck then stalled, I observed smoke coming from under the hood, I exited vehicle to try and open hood, but flames were already present, I called 911 fire department came and put fire out. truck is a total loss. Fire Capt observed that fire seem to have started near the fuel filter housing, I was fortunate to escape the cab along with my dog, I have read several reports about filter housing leaking and starting fires, my brother inlaw, actually had the same issue, filter split causing fuel to leak, but fortunately he had just started the truck and wa
The contact owns a 2020 Ford F-550. The contact stated that while driving at 20 MPH, the fuel injector became inoperable. The check engine warning light became illuminated. The vehicle was taken to the local dealer, where it was diagnosed, and determined that the fuel injectors needed to be replaced. The vehicle was repaired. The manufacturer was contacted and confirmed that the part to repair the vehicle under NHTSA Campaign Number: 24V957000 (Fuel System, Diesel) was on back order and that a second notification would be forwarded once parts became available. The failure mileage was approximately 85,172.
The contact owns a 2020 Ford F-550. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the remedy was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.Â
At ~93,000 miles, my 2020 Ford F-550 (7.3L âGodzillaâ V8) suffered catastrophic engine failure due to a roller lifter bearing failure, causing internal valvetrain damage and requiring full engine replacement. Ford dealer stated they recommended 90% coverage of the repair under goodwill through corporate, but later reduced coverage to 40% without explanation. After repairs, Ford corporate recommended a 3-year/36,000-mile PremiumCare warranty, then rescinded it a week later and offered only free oil changes. The 7.3L engine in my truck shares the same design as the F-53/F-59 motorhome chassis, which have multiple Technical Service Bulletins (TSBs) for lifter bearing failure, overheating
2020 Ford F-550 questions
Does the 2020 Ford F-550 have any recalls?
Yes. NHTSA lists 2 safety recalls for the 2020 Ford F-550: Low Rear Axle Fluid Can Cause Driveshaft Separation; Seatback May Not Hold in a Crash, Raising Injury Risk. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2020 Ford F-550?
Based on 17 owner complaints filed with NHTSA, the most-reported problem areas are Fuel System, Diesel (6), Power Train (3), Suspension (3).
How do I check if a recall on my 2020 Ford F-550 has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.