CarRecallWatchThe 2018 Ford F-450 has 3 safety recalls on file with NHTSA.
Owners have filed 10 complaints with NHTSA, including 1 fire.
The most-reported problem area is Engine (3 reports).
2018 Ford F-450 recalls
Backup camera image may flip, risking a crash
Certain 2018-2019 commercial vehicles built on Ford and Freightliner chassis with ASA Electronics Voyager back-up camera displays may unexpectedly switch to the factory default settings.
Brake lights may light up without the brake pedal pressed
Some 2017-2018 ambulances built on Ford E-350, E-450, F-450, and F-550 chassis, and GMC G3500 chassis, were equipped with Whelen brake lights that, depending on how the vehicle is wired, may illuminate even when the brake pedal has not been pressed.
Engine block heater cable can corrode and cause fire
Water and contaminants can enter the splice connector on the engine block heater cable, causing corrosion and damage.
Most common 2018 Ford F-450 problems
Problem areas named in the 10 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Engine | 3 |
| Wheels | 2 |
| Steering | 2 |
| Electrical System | 2 |
| Fuel/Propulsion System | 2 |
| Suspension | 1 |
| Back Over Prevention | 1 |
| Unknown Or Other | 1 |
| Engine And Engine Cooling | 1 |
What owners report
incidents Summary: The vehicle experienced a significant engine compartment fire while in operation. The fire originated in the engine valley near the secondary fuel filter, consistent with the failure mode described in NHTSA Investigation PE24014. 1. Component Failure & Part Numbers: The fire necessitated an $18,000 repair (RO #443426). Based on the repair invoice, the following safety-critical components were heat-destroyed and replaced: Secondary Fuel Filter (PC3Z9N184C) Main Engine Wiring Harness (HC3Z12B637A) Inlet Manifold (GC4Z9424A) High-Pressure Fuel Pipes (HC3Z9J280J and BC3Z9E964A) Cowl Grilles (HC3Z25022A68AB/69AC) 2. Safety Risk & Pre-Existing Symptoms: Prior to the fire,
My truck is outfitted with the CP4 fuel pump. These pumps are failing on a regular basis and destroying entire fuel systems costing the vehicle owner as much as $20,000 to replace. If this pump goes out while driving, it could be a major safety issue. I tow a 44 foot trailer with my truck and this can cause a deadly accident. I called Ford and there is no recall as of now. There are attorneys out there using the Lemon Law act to go after the ones that have failed so far. These pumps are not designed to be used with American Diesel. They are made in Europe and designed for their fuel. I am just trying to prevent an accident. Iâd like Ford to just recall this pump and replace it.
The contact owns a 2018 Ford F-450. The contact stated that upon having the vehicle serviced, he was made aware that there were metal shavings found inside the oil pan, and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 91,000.
The contact owns a 2018 Ford F-450. The contact stated that while driving at various speeds, the check engine warning light remained illuminated, and the vehicle failed to properly accelerate. The vehicle was taken to the local dealer who replaced the turbo charger. After retrieving the vehicle, the failure immediately reoccurred. The vehicle was taken back to the dealer who diagnosed that the diesel particulate filter was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 51,000.
The rear camera is addressed in NHTSA Recall Number22V644, but the same issue is occurring with the front camera too. Ford dealer said to call Ford customer service to address my concern. Ford customer service advised I file a claim with NHTSA. Since Ford already acknowledged the issue with these cameras, Iâd like the front to be addressed at the same time as the rear.
2018 Ford F-450 questions
Does the 2018 Ford F-450 have any recalls?
Yes. NHTSA lists 3 safety recalls for the 2018 Ford F-450: Backup camera image may flip, risking a crash; Brake lights may light up without the brake pedal pressed; Engine block heater cable can corrode and cause fire. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2018 Ford F-450?
Based on 10 owner complaints filed with NHTSA, the most-reported problem areas are Engine (3), Wheels (2), Steering (2).
How do I check if a recall on my 2018 Ford F-450 has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.