2007 Chevrolet Express 2500 Recalls, Problems & Safety Rating

2007 Chevrolet Express 2500 recalls

No safety recalls on file for the 2007 Chevrolet Express 2500.

Most common 2007 Chevrolet Express 2500 problems

Problem areas named in the 7 complaints owners filed with NHTSA.

Problem area	Reports
Service Brakes, Hydraulic	2
Tires	2
Structure	2
Wheels	1
Engine	1
Steering	1
Power Train	1
Electrical System	1

What owners report

2015-10-13, Tires
TL* THE CONTACT OWNS A ROAD TREK POPLAR TRAILER (NA) EQUIPPED WITH REPLACEMENT BF GOODRICH COMMERCIAL T/A A/S TIRES, SIZE LT 245/75R16. THE TRAILER WAS HITCHED TO A 2007 CHEVROLET EXPRESS 2500. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE BEGAN TO SHAKE. UPON INSPECTION IT WAS DISCOVERED THAT THE REAR PASSENGER SIDE TIRE EXPERIENCED A SLIGHT BULGE IN THE MIDDLE OF THE TREAD. THE TIRE WAS REPLACED BY THE RETAILER. THE CONTACT EVENTUALLY EXPERIENCED THE SAME FAILURE ON ALL FOUR TIRES. EACH FAILURE WAS ON THE REAR PASSENGER AND DRIVER SIDE TIRES. ON JULY 19, 2015, WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE BEGAN TO SHAKE BEFORE THE PASSENGER SIDE REAR TIRE EXPERIENCED A BLOW OUT. THE MA

2014-03-20, Electrical System
I WAS THE SOLE OCCUPANT. CONCERNING THE INFORMATION ABOVE THE DATE IS ACCURATE WITHIN ABOUT A WEEK AND MAY BE DETERMINED EXACTLY. MILEAGE IS CORRECT WITHIN A THOUSAND MILES. MY INJURIES WERE NOT MAJOR AND I DECLINED TREATMENT SPECIFICALLY BECAUSE I NEEDED TO DEAL WITH THE WRECKER AND SUCH. END OF PREAMBLE I WAS LEAVING THE GARAGE AT THE CONDO WHERE I LIVE. THERE IS A STEEP INITIAL GRADE ENDING IN A 90 DEG. LEFT FOLLOWED BY A MORE MODEST DECLINE ENDING AT A STREET WITH TRAFFIC. BECAUSE THE RAMP IS NARROW AND EVERYTHING DISAPPEARS FROM THE DRIVER'S VIEW, I WAS TAPPING THE BRAKES AND CHECKING THE POSITION OF THE BACK WHEELS, WHEN THE BRAKE PEDAL CEASED TO FUNCTION. I TRIED IT AT LEAST TWI

2013-05-29, Structure
THE HINGE ON THE SIDE CARGO DOOR BROKE WHILE CLOSING THE DOOR I HAD TO TIE IT SHUT FROM INSIDE. VERY SAFE. ACCORDING TO NUMEROUS FORUMS, THE HINGES ON THESE VANS ARE NOTHING BUT A PROBLEM. NO IT'S GOING TO COST $1000 TO FIX A PROBLEM THAT CHEVY SHOULD HAVE ADDRESSED MANY YEARS AGO. *TR ## VIN FAILED ##

2012-09-19, Engine
TL* THE CONTACT OWNS A 2007 CHEVROLET EXPRESS 2500. THE CONTACT STATED THAT HE NOTICED OIL LEAKING FROM THE VEHICLE. THE CONTACT FURTHER INSPECTED THE VEHICLE AND DISCOVERED THAT THE LEAK WAS COMING FROM THE COOLING COMPARTMENT. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY ADVISED THAT THERE WAS A PIPE THAT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED AND PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 77,000. UPDATED 10/26/12 *CN THE CONSUMER STATED ALL 4 BRAKE ROTORS FAILED STATE INSPECTION. THE ROTORS WERE RUSTED. AT 97,000 MILES THE TRANSMISSION FAILED AFTER REPLACEMENT. ALL FOUR STEEL RIMS WERE HEAVILY RUSTED INSIDE AND OUT. COOLI

2012-05-16, Tires
TIRE VALVE STEM BROKE WHILE THE TIRE PRESSURE WAS BEING CHECKED. THIS OCCURRED DURING AN OIL CHANGE SERVICE. THE BROKEN VALVE STEM/TPMS SENSOR REQUIRED $82 TO REPAIR IT. I AM FILING THIS CLAIM ON BEHALF OF OUR CUSTOMER.

2007 Chevrolet Express 2500 questions

Does the 2007 Chevrolet Express 2500 have any recalls?

No. NHTSA has no safety recalls on file for the 2007 Chevrolet Express 2500 at this time.

What are the most common problems with the 2007 Chevrolet Express 2500?

Based on 7 owner complaints filed with NHTSA, the most-reported problem areas are Service Brakes, Hydraulic (2), Tires (2), Structure (2).

How do I check if a recall on my 2007 Chevrolet Express 2500 has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.