2005 Chevrolet Express 2500 Recalls, Problems & Safety Rating

2005 Chevrolet Express 2500 recalls

No safety recalls on file for the 2005 Chevrolet Express 2500.

Most common 2005 Chevrolet Express 2500 problems

Problem areas named in the 9 complaints owners filed with NHTSA.

Problem area	Reports
Structure	3
Tires	2
Suspension	1
Power Train	1
Air Bags	1
Seat Belts	1
Exterior Lighting	1
Equipment Adaptive/Mobility	1
Latches/Locks/Linkages	1

What owners report

2015-07-14, Tires
CATASTROPHIC SIDEWALL FAILURE IN TIRE WHILE TRAVELING IN TRAFFIC AT 50MPH. DRIVER SIDE REAR TIRE COMPLETELY FAILED AND UPON REMOVAL- NOTICED SIDEWALL SPLIT. UPON IMMEDIATE INSPECTION OF PASSENGER REAR TIRE, NOTICED SAME SPLIT IN SIDEWALL OF TIRE, WITH FAILURE IMPENDING. 55.000 MILETIRES HAVE 31000 MILES- ROTATED NORMALLY, AIR PRESSURE AS PER RECOMMENDATIONS. MAIN PROBLEM- THERE ARE 2 MORE TIRES ON THE FRONT- SAME MANUFACTURE AND MAKE- CLASSIFICATION RATING.

2013-09-05, Structure
VEHICLE WAS TAKEN IN FOR INSPECTION AND FAILED DUE TO THE TRANSMISSION CROSS MEMBER RUSTING OUT. IT IS 7 YEARS OLD BUT HAS LOW MILEAGE. I DO NOT FEEL THAT FAILURE OF THE FRAME SHOULD HAPPEN I WAS TOLD THAT THIS FAILURE DUE TO RUST IS COMMON ON THESE VANS AND THEY MAKE A REPLACEMENT CROSS MEMBER THAT BOLTS RIGHT IN BECAUSE OF THIS PROBLEM. I HAVE ALREADY HAD TO REPLACE ABS SENSORS DUE TO CORROSION AND NOW THIS, BOTH ARE SAFETY PARTS AND FAILED BECAUSE THEY ARE NOT DESIGNED FOR THE NORMAL WEAR AND TEAR IN NORTHERN STATES. *JB

2013-07-26, Structure
PASSENGER SIDE DOUBLE DOOR HINGES GOT SO TIGHT THAT THEY SNAPPED THE HINGE. NO LUBE WOULD LOOSEN PRIOR TO BREAKING. THIS WEEK THE RIGHT DOOR EXACT SAME THING. HINGE SNAPPED. THE ORIGINAL HINGES ARE DEFECTIVE AND ARE UNABLE TO BE LUBED. THEY KNOW THEY HAVE A PROBLEM BECAUSE THE NEW ONES ARE MADE WITH GREASE FITTINGS. I JUST LOOKED ON LINE AT A FORUM AND THERE ARE SEVERAL LISTINGS FOR THE SAME PROBLEM FOR YEARS. *TR

2010-11-18, Structure
LAST YEAR PASSENGER SIDE DOUBLE DOOR LEFT SIDE HINGES GOT SO TIGHT THAT THEY SNAPPED THE HINGE. NO LUBE WOULD LOOSEN PRIOR TO BREAKING. THIS WEEK THE RIGHT DOOR EXACT SAME THING. HINGE SNAPPED. REPLACED THIS ONE COSTING ME $800. LAST YEAR WAS PROBABLY THE SAME COST FOR THE LEFT. THE ORIGINAL HINGES ARE DEFECTIVE AND ARE UNABLE TO BE LUBED. THEY KNOW THEY HAVE A PROBLEM BECAUSE THE NEW ONES ARE MADE WITH GREASE FITTINGS. I JUST LOOKED ON LINE AT A FORUM AND THERE ARE SEVERAL LISTINGS FOR THE SAME PROBLEM FOR YEARS. *TR

2010-06-03, Equipment Adaptive/Mobility
TL* THE CONTACT OWNS A 2005 CHEVROLET EXPRESS 2500 VAN. THE CONTACT STATED THAT THE PASSENGERS SIDE CLAM SHELL DOOR HINGES WERE DEFECTIVE AND WERE DIFFICULT TO OPEN. INTERMITTENTLY, THE DOOR WOULD BECOME STUCK. THE DEALER WAS CONTACTED AND ADVISED ALTHOUGH THERE WAS A RECALL FOR THE FAILURE, THE CONTACTS VIN WAS NOT INCLUDED IN THE RECALL (NHTSA CAMPAIGN ID NUMBER 09V307000: EQUIPMENT ADAPTIVE).THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 26,000.

2005 Chevrolet Express 2500 questions

Does the 2005 Chevrolet Express 2500 have any recalls?

No. NHTSA has no safety recalls on file for the 2005 Chevrolet Express 2500 at this time.

What are the most common problems with the 2005 Chevrolet Express 2500?

Based on 9 owner complaints filed with NHTSA, the most-reported problem areas are Structure (3), Tires (2), Suspension (1).

How do I check if a recall on my 2005 Chevrolet Express 2500 has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.