CarRecallWatchThe 2019 Chevrolet 5500HD has 3 safety recalls on file with NHTSA.
Owners have filed 6 complaints with NHTSA, including 1 fire.
The most-reported problem area is Service Brakes (2 reports).
2019 Chevrolet 5500HD recalls
Brake fluid leak can cause electrical short and fire risk
Certain Chevrolet medium-duty trucks may have a brake pressure sensor assembly that leaks brake fluid into the brake pressure switch.
Loose Rear Axle Bolts Can Cause Loss of Power
Rear axle U-bolt nuts on certain trucks may not have been properly tightened, and they can loosen over time.
Loose Rear Wheel Lug Nuts Can Let Wheels Separate
Some rear outer wheels on these trucks may not have had their lug nuts properly tightened when installed on the rear axles.
Most common 2019 Chevrolet 5500HD problems
Problem areas named in the 6 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Service Brakes | 2 |
| Fuel/Propulsion System | 2 |
| Electrical System | 1 |
| Power Train | 1 |
| Engine | 1 |
| Service Brakes, Hydraulic | 1 |
What owners report
The contact owns a 2019 Chevrolet Silverado 6500 Commercial Vehicle. The contact stated that the recall repair of NHTSA Campaign Number: 23V266000 (Service Brakes, Hydraulic) was previously performed on the vehicle. The contact stated while the driver was driving 55-60 MPH uphill, he noticed smoke coming from underneath the driver's side of the hood. The contact stated that the driver depressed the brake pedal several times, but the brake pedal went down to the floorboard, and the vehicle failed to respond. The driver veered to the side of the road and allowed the vehicle to roll to a stop. The messages "Engine Power Reduced" and "Service Emission System" were displayed. The driver exited th
Sudden catastrophic fuel system failure due to contamination fuel and fuel filter bypass, yes it is available to inspect. Truck shut off during operations and did not restart, the vehicle is at the dealership to replace High pressure fuel pump, lines, fuel rail and injectors. After the the truck died there was a message in the message center "water in fuel, service". The truck never sputtered, no loss of power or engine light. No codes were thrown either.
WATER LINE CRACKING LEAKING ANTIFREEZE OVERHEATING ENGINE
WHEN DRIVING, IT FEELS LIKE IM RIDING ON RUMBLE STRIPS. TRANSMISSION FEELS LIKE ITS SLIPPING WHEN DRIVING AT LOWER SPEEDS AND WHEN ON THROTTLE, LIKE GOING UP HILL. DO NOT NOTICE A DIFFERENCE IN 4X4 MODE. TRUCK ALSO HAS HARD SHIFTING FROM 1-2 AND 2-3RD GEAR.
MY TRUCK WILL STOP RUNNING AT FREEWAY SPEEDS WITH NO ENGIN LIGHT HAVE HAD TO STOP IN TRAVEL LANE TO RESTART THE TRUCK THE BRAKES WILL SHAKE STEERING WHEEL OUT OF YOUR HANDS AND MUTIPUL EMISSION RELATED ENGIN LIGHTS DAILY THE TRUCK IS ONLY 3 WEEKS OLD THE ENGIN BRAKE SHIFTS FROM OVER DRIVE TO 3RD OR SECOND GEAR REDLINING THE MOTOR AND U HAVE TO APPLY WIDE OPEN THEOTTLE WHILE PULLING A TRAILER DOWN A STEEP GRADE VERY UNSAFE
2019 Chevrolet 5500HD questions
Does the 2019 Chevrolet 5500HD have any recalls?
Yes. NHTSA lists 3 safety recalls for the 2019 Chevrolet 5500HD: Brake fluid leak can cause electrical short and fire risk; Loose Rear Axle Bolts Can Cause Loss of Power; Loose Rear Wheel Lug Nuts Can Let Wheels Separate. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2019 Chevrolet 5500HD?
Based on 6 owner complaints filed with NHTSA, the most-reported problem areas are Service Brakes (2), Fuel/Propulsion System (2), Electrical System (1).
How do I check if a recall on my 2019 Chevrolet 5500HD has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.