CarRecallWatchThe 2005 BMW K1200 S has 7 safety recalls on file with NHTSA.
Owners have filed 15 complaints with NHTSA, including 2 crashes, 2 injuries.
The most-reported problem area is Fuel/Propulsion System (5 reports).
2005 BMW K1200 S recalls
Fuel Pump Flange May Crack, Causing Leaks and Fire Risk
The fuel pump flange on certain BMW motorcycles that were previously repaired under recall 13V-617 with the support ring remedy may crack.
Rear Wheel Can Loosen and Cause Loss of Control
The rear wheel mounting flange, which is aluminum on the affected motorcycles, may crack if the rear wheel mounting bolts are overtightened.
Most common 2005 BMW K1200 S problems
Problem areas named in the 15 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Fuel/Propulsion System | 5 |
| Power Train | 3 |
| Service Brakes | 3 |
| Fuel System, Gasoline | 2 |
| Engine And Engine Cooling | 2 |
| Suspension | 1 |
| Engine | 1 |
| Steering | 1 |
| Structure | 1 |
| Electrical System | 1 |
What owners report
*2005 BMW K1200s ABS Power Brake system became and is Intermittent. Is available for inspection. Dealer owner and mechanic stated they were unaware of any said BMW ABS problems * On my birthday , Riding my motorcycle approximately 40mph, no indicator light on, no prier symptoms existed and unaware that the ABS Power Brake system was (off) not operating and as I needed to slow down, the system allowed me to over press/squeeze front power brake lever. Front Power BRAKE turned on and I eminently became a member of The over the Handle Bar's Club. * Woke up in the Hospital with broken Collar Bone, 3 damaged Ribs and a heavy Head Concussion * HPD Officers Report was inadequate
MY MOTORCYCLE IS LEAKING GASOLINE SOMEWHERE. I CAN'T LEAVE IT IN THE GARAGE DUE TO THE STRONG GAS SMELL. I'VE REMOVED THE FAIRING, BUT STILL CAN'T FIND WHERE THE LEAK IS COMING FROM.
ON SUNDAY NOVEMBER 7TH I WAS RIDING MY 2005 BMW K1200S ON A ROUNDTRIP FROM LITTLE ROCK, AR TO PETIT JEAN MOUNTAIN STATE PARK. APPROXIMATELY 20 MILES FROM HOME ON HWY 300 NEAR THE LITTLE ITALY TOWNSHIP I EXPERIENCED COMPLETE BRAKE/ABS FAILURE WHILE TRAIL BRAKING THROUGH A TURN. THIS IS A ROAD WITH SEVERAL STEEP AND TIGHT HAIRPIN TURNS AND VERY LIMITED/NON-EXISTENT RUNOFF ROOM. I RAN WIDE ON THE NEXT CORNER AND ENDED UP CROSSING THE DOUBLE YELLOW AND WAS NEARLY HIT BY AN ONCOMING CAR. FORTUNATELY I WAS ABLE TO USE THE GEARBOX TO DOWNSHIFT AND USED ENGINE BRAKING TO SLOW MY MOTORCYCLE DOWN TO A SAFE (ALREADY BELOW THE SPEED LIMIT) SPEED. I PULLED OVER ONCE I CAME TO A SHORT STRAIGHT SECTION OF
WHILE AT FREEWAY SPEED (65-75 MPH) AN AUDIBLE CHANGE TO THE OVERALL SOUND AND FEEL OF THE MOTORCYCLE OCCURRED. DISENGAGING THE CLUTCH HAD NO AFFECT ON THE SOUND. THE TONE WAS IMPACTED BY SLOWING DOWN AND WAS NO LONGER AUDIBLE AT REST. SHORTLY AFTER, MY SPEEDOMETER AND ODOMETER COMPLETELY FAILED. PUSHING THE BIKE BACKWARDS RESULTED IN THE GEARING BEING JAMMED PREVENTING REVERSE TRAVEL. PUSHING FORWARD WAS POSSIBLE. UPON REMOVAL OF THE FINAL GEAR (ANGLE DRIVE) HOUSING COVER, I DISCOVERED THAT 2 TEETH ON THE RING GEAR HAD BROKEN OFF CAUSING ADDITIONAL DAMAGE TO THE PINION GEAR AND THE HOUSING. THE TWO BROKEN TEETH WE RECOVERED IN THE HOUSING. THE OBVIOUS SAFETY CONCERN IS IF THOSE BRO
RIDING APPROXIMATELY 45MPH AND APPROACHING A TRAFFIC LIGHT THAT TURNED YELLOW, I ATTEMPTED TO STOP USING THE HANDBRAKE. BRAKING WAS NEARLY NONEXISTENT AND IMMEDIATELY A RED WARNING LIGHT APPEARED ACCOMPANIED BY A BRAKE FAILURE LIGHT. THE FOOT BRAKE DID NOT FUNCTION AS WELL. AT THIS POINT THE LIGHT WAS TURNING RED AND I HAD NO CHANCE OF DOWNSHIFTING TO USE ENGINE BRAKING, SO MY ONLY HOPE TO AVOID AN ACCIDENT WAS TO DOWNSHIFT AND PROCEED THROUGH THE INTERSECTION. I HAD LOST ALL BRAKING ABILITY ON A MOTORCYCLE WHILE TRAVELING OVER 40MPH IN A HEAVY TRAFFIC AREA. ONLY BY PURE LUCK WAS THERE NO ACCIDENT. AFTER TRAILERING THE MOTORCYCLE HOME, I DID SOME RESEARCH AND DISCOVERED THAT THIS IS A VER
2005 BMW K1200 S questions
Does the 2005 BMW K1200 S have any recalls?
Yes. NHTSA lists 7 safety recalls for the 2005 BMW K1200 S: Fuel Pump Flange May Crack, Causing Leaks and Fire Risk; Rear Wheel Can Loosen and Cause Loss of Control; Fuel System, Gasoline:Delivery:Fuel Pump; Suspension:Rear; Engine And Engine Cooling. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2005 BMW K1200 S?
Based on 15 owner complaints filed with NHTSA, the most-reported problem areas are Fuel/Propulsion System (5), Power Train (3), Service Brakes (3).
How do I check if a recall on my 2005 BMW K1200 S has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.