2005 BMW 525i Recalls, Problems & Safety Rating

2005 BMW 525i recalls

No safety recalls on file for the 2005 BMW 525i.

Most common 2005 BMW 525i problems

Problem areas named in the 35 complaints owners filed with NHTSA.

Problem area	Reports
Air Bags	23
Seat Belts	7
Seats	6
Power Train	4
Electrical System	4
Unknown Or Other	3
Steering	1
Fuel/Propulsion System	1
Exterior Lighting	1
Service Brakes	1

What owners report

2024-10-23, Service Brakes
I am encountering persistent issues with my 2005 BMW 525i. Despite having replaced several critical components, including the ignition coils, spark plugs, mass air flow sensor, and throttle body sensors, the vehicle continues to experience performance problems, specifically failing to advance beyond the fourth cylinder when driving uphill. After conducting numerous diagnostic tests, I have concluded that there may be an air leak in the intake manifold. Additionally, after prolonged use under these conditions, the positive battery cable from the trunk has shown signs of overheating, evidenced by smoke, which I suspect is related to repeated uphill driving. While the vehicle performs adequat

2024-05-15, Exterior Lighting
The tail-lights have gone out creating safty issue and number of warning lights to come up on the dashboard. Dealership stated that the wiring harness around ground wire has melted. They stated that this is same issue that is mentioned under NHTSA Campaign Number: 13V407000. The service advisor said that his issue would be fixed by same service bulletin SIB 630613, however my date range is not included in the recall. I would like to report an issue to open a case and extend the recall to include all E60 models from 2004 to 2010. Would you please open an investigation into this matter and contact me for additional information and photos.

2019-02-06, Power Train
I PURCHASED THIS BMW 525I USED FROM A PERSON THAT OBTAINED IT FROM A WHOLESALE DEALER, IT HAD SOME MINOR FRONTEND DAMAGE FROM A FENDER BENDER (BROKEN GRILL, DING TO HOOD) SHOWING 107900 MILES. EVERYTHING ELSE CHECKED OUT. I FEW MONTHS LATER I NOTICED A SLIGHT CHANGE IN TRANSMISSION SOUND, BUT IT MIGHT HAVE BEEN DUE TO THE COLD TEMPERATURES HERE IN WISCONSIN. A COUPLE OF DAYS LATER WHILE JUST FINISHING GOING UP A SLIGHT STRAIGHT INCLINE AT AROUND 45MPH THE TRANSMISSION DROPPED DOWN INTO LIMP DOWN MODE AND A TEMPORARY NOTICE CAME UP ON THE COMPUTER SCREEN INDICATING A TRANSMISSION PROBLEM. STOPPING AND RESTARTING THE ENGINE CLEARED THE PROBLEM, THE NEXT DAY NEAR THE SAME SPOT IT OCCURRED

2018-11-15, Fuel/Propulsion System
MY CAR HAS A GAS SMELL EVEN IN THE INSIDE SMELLS LIKE GAS

2018-01-09, Air Bags
AFTER HAVING AN INDEPENDENT MECHANIC SCAN MY VEHICLE WITH AN ADVANCED SCAN TOOL, THE ERROR THAT CAME UP WAS FOR THE "PASSENGER SEAT OCCUPANCY SENSOR". THIS FAULT HAS CAUSED BOTH THE AIRBAG AND SEATBELT LIGHT TO REMAN ILLUMINATED CONTINUOUSLY. THE FIRST TIME IT HAPPENED, I HAD THE CODE RESET. BUT AFTER A PERSON SAT IN THE PASSENGER SEAT, THE ERROR CODE CAME BACK WITH THE SAME FAULT CODE.

2005 BMW 525i questions

Does the 2005 BMW 525i have any recalls?

No. NHTSA has no safety recalls on file for the 2005 BMW 525i at this time.

What are the most common problems with the 2005 BMW 525i?

Based on 35 owner complaints filed with NHTSA, the most-reported problem areas are Air Bags (23), Seat Belts (7), Seats (6).

How do I check if a recall on my 2005 BMW 525i has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.