CarRecallWatchThe 2015 BMW 320i has 3 safety recalls on file with NHTSA.
Owners have filed 34 complaints with NHTSA, including 1 fire.
The most-reported problem area is Engine (11 reports).
2015 BMW 320i recalls
Driver airbag inflator may explode, sending metal fragments at occupants
The driver's frontal airbag inflator may rupture during deployment because of a manufacturing defect.
Side Airbag Inflator May Rupture or Leak Gas
The side head airbag inflators in these BMW 2 Series, 3 Series, and 4 Series vehicles may fail at a weld joint.
Front side marker lights may stay off, raising crash risk at night
Some BMW 3 Series and ActiveHybrid3 vehicles may have been programmed with software that can cause the front side marker lights to stay off when the parking lights or headlights are on.
Most common 2015 BMW 320i problems
Problem areas named in the 34 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Engine | 11 |
| Fuel/Propulsion System | 8 |
| Unknown Or Other | 7 |
| Electrical System | 5 |
| Exterior Lighting | 4 |
| Structure | 3 |
| Wheels | 2 |
| Electronic Stability Control (Esc) | 1 |
| Back Over Prevention | 1 |
| Air Bags | 1 |
What owners report
My 2015 BMW 320i (VIN: [XXX]) intermittently loses power steering assistance while driving, creating a serious safety concern. BMW Service Bulletin SI [XXX] describes similar EPS-related issues. Given the nature of this failure, I believe it deserves further review beyond the vehicleâs warranty status. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The fuel system was causing my engine to shut down, and I got it replaced at a mechanic. About some time later, after fixing the fuel system, I received a letter from BMW telling me that they had extended the warranty on the Fuel tank, but when I took it in, they said that there was no such extended warranty. The letter is from April 2022, but I just recently found it.
My 2015 BMW 320 is having a performance issue. After I diagnosed this is due to corrosion on the wastegate actuator and has failed. The bushing and part corroded and the rod is dangling. This should be covered by the extended warranty on the part as itâs a known defect failure by BMW
Vehicle continues to have lighting and electrical issues. Particularly, the left rear turn signal. Iâve repaired it 5 times and it burns out immediately. Dealer assured me they would find issue. Still burned out next day again. Notified dealership and they just want you to keep bringing it back but wonât issue a recall despite the plethora of complaints online about the same issue.
The gas tank on my BMW 320i 4 door sedan is leaking gas. Yes; it is available for inspection upon request. I had picked up my son from school and ran an errand. We stopped for gas when we noticed the gas was leaking as soon as we filled up the tank. We were around the corner from our home and drove home very slow. We were prepared to stop and pull over if necessary as we were afraid of the vehicle catching fire. I have an appointment with Niello BMW at 8am on 9/22/25 in Sacramento, CA on Fulton Ave. There were no warning lamps/messages or other symptoms prior to the issue. I never received any recall notification.
2015 BMW 320i questions
Does the 2015 BMW 320i have any recalls?
Yes. NHTSA lists 3 safety recalls for the 2015 BMW 320i: Driver airbag inflator may explode, sending metal fragments at occupants; Side Airbag Inflator May Rupture or Leak Gas; Front side marker lights may stay off, raising crash risk at night. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2015 BMW 320i?
Based on 34 owner complaints filed with NHTSA, the most-reported problem areas are Engine (11), Fuel/Propulsion System (8), Unknown Or Other (7).
How do I check if a recall on my 2015 BMW 320i has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.