2004 Workhorse W22 Recalls, Problems & Safety Rating

2004 Workhorse W22 recalls

Most common 2004 Workhorse W22 problems

Problem areas named in the 92 complaints owners filed with NHTSA.

Problem area	Reports
Service Brakes, Hydraulic	75
Service Brakes	6
Electrical System	4
Engine And Engine Cooling	4
Fuel System, Gasoline	3
Service Brakes, Air	3
Service Brakes, Electric	2
Power Train	2
Equipment	2
Structure	1

What owners report

2023-07-06, Service Brakes, Hydraulic
The contact owns a 2004 Workhorse W22. The contact stated that after the RV was stored for several years, the contact learned that the brakes had seized. The contact then became aware that the RV was included in a recall. The RV was taken to the dealer and repaired under NHTSA Campaign Number: 09V110000 (Service Brakes, Hydraulic) however, the RV experienced brake failure. The contact stated that after the repair due, to personal issues, he was unable to use the RV for several months. The contact stated that he recently started driving the RV around the property and locally; however, he became aware of brake fluid leaking underneath the RV. There was no warning light illuminated. The contact

2022-09-28, Service Brakes
The contact owns a 2004 Workhorse W22 RV. The contact stated while driving approximately 60 MPH, the brakes heated up and seized. The contact stated that the ABS warning light was illuminated. The contact pulled over and smelled a burning odor. The contact stated that he waited for over one hour for the brakes to cool and then he continued driving to his destination. The contact stated that the failure became constant and he no longer took the RV on long trips. The contact had taken the RV to an independent mechanic where it was diagnosed and determined that the calipers, pistons, sensors, and rotors needed to be replaced. The RV had been repaired; however, the failure reoccurred. The manufa

2022-09-07, Service Brakes, Hydraulic
The contact owns a 2004 Newmar Kountry built on a 2004 Workhorse W22 chassis. The contact stated while driving 70 MPH, the brake pedal was depressed but failed to respond as needed. The contact was able to continue driving. The vehicle was taken to an independent mechanic on four occasions where the brake pads were replaced four times however, the failure persisted. The contact stated while driving on a wet road surface and attempting to make a stop at the stop sign, the vehicle slid into a ditch. The contact did not sustain any injuries. The contact was able to pull the RV out of the ditch with the assistance of a four-wheel drive vehicle. The contact’s friend, an independent mechanic, ar

2018-04-03, Service Brakes
2004 CHEVROLET GULF STREAM. CONSUMER WRITES IN REGARDS TO BRAKE SYSTEM RECALL REPAIR ISSUES - RIGHT FRONT CALIPER/ABS SENSOR REPLACEMENTS. *SMD *TR

2016-07-11, Service Brakes
2000 MILES AFTER RECALL WAS FIXED WHEN BRAKES APPLIED STEERING WHEEL PULLS YOUR HANDS OFF AND GOES TO THE RIGHT AND CANT KEEP IT IN THE ROAD.

2004 Workhorse W22 questions

Does the 2004 Workhorse W22 have any recalls?

Yes. NHTSA lists 2 safety recalls for the 2004 Workhorse W22: Service Brakes, Hydraulic; Engine And Engine Cooling. Recall repairs are normally free at an authorized dealer.

What are the most common problems with the 2004 Workhorse W22?

Based on 92 owner complaints filed with NHTSA, the most-reported problem areas are Service Brakes, Hydraulic (75), Service Brakes (6), Electrical System (4).

How do I check if a recall on my 2004 Workhorse W22 has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.