2011 Volvo XC90 Recalls, Problems & Safety Rating

2011 Volvo XC90 recalls

Most common 2011 Volvo XC90 problems

Problem areas named in the 19 complaints owners filed with NHTSA.

Problem area	Reports
Engine	5
Electrical System	5
Power Train	3
Engine And Engine Cooling	2
Seat Belts	2
Service Brakes	2
Steering	2
Fuel System, Gasoline	1
Vehicle Speed Control	1
Structure	1

What owners report

2026-02-05, Engine
The catillatic converter exploded as we started the vehicle .was a very loud explosion..no fire but lots of smoke.

2022-02-24, Engine
The contact owns a 2011 Volvo XC90. The contact stated that the check engine warning lights was illuminated. The vehicle was not taken to a local dealer. The manufacturer was informed of the failure and suggested that the vehicle be taken to a dealer to be diagnosed. The failure mileage was approximately 128,000.

2022-02-17, Electrical System
Electrical, Brake lights suddenly stopped working on both sides at once. I checked the fuse only to be told a relay may be the issue. The location of said relay is vague and not serviceable by owner. Risk of rear end collision. Of following traffic

2021-04-20, Electrical System
94,000 MILES 2011 VOLVO XC90 PURCHASED 4 MONTHS AGO. VEHICLE WAS PARKED STATIONARY IN DRIVEWAY. IN THE MIDDLE OF THE NIGHT WATER INTRUDED THE FRONT PASSENGER CABIN AND DASHBOARD OF THE VEHICLE THROUGH A SUNROOF DRAINAGEDEFECT IN THIS YEAR AND MODEL OF VOLVO XC90. SIX INCHES OF WATER POOLED IN THE FRONT PASSENGER FLOOR AND PERMEATED THE DASH CAUSING THE CEM TO SHORT AND START AN ELECTRICAL FIRE. THE CABIN OF THE VEHICLE FILLED WITH THICK SMOKE FROM THE ELECTRICAL FIRE AND THE CAR ALARM BEGAN TO GO OFF. THE ELECTRICAL FIRE BEGAN IN THE DRIVER COMPARTMENT HOUSING THE CEM. THE CEM WIRES WERE COMPLETELY MELTED AWAY. MULTIPLE ELECTRICAL SYSTEMS EFFECTED AND REQUIRE REPLACEMENT PLUS SMOKE/FIRE/WATE

2020-12-15, Seat Belts
DRIVER SEAT BELT DOES NOT FULLY RETRACT AFTER EVERY RELEASE. IT WILL BE LOOSE UNTIL YOU GUIDE IT UP TO THE HOLE. IT IS KIND OF OKAY FOR NOW BUT I HAVE NO DOUBT THIS ISSUE COULD GET WORSE. I AM ALSO ALMOST CERTAIN THIS IS SIMILAR TO RECALL #R10029 THAT AFFECTS OUR 2011 XC60. THE PART MUST BE WORN. IT STILL RETRACTS AROUND PEOPLE BUT IF IT GETS WORSE, IT COULD BE FATAL DOWN THE LINE IF IT DOES NOT RETRACT PROPERLY WITH A SMALLER DRIVER. PASSENGER BELT IS FINE. RIGID AND FIRM AS PICTURES SHOW UNLIKE THE DRIVER SIDE.

2011 Volvo XC90 questions

Does the 2011 Volvo XC90 have any recalls?

Yes. NHTSA lists 1 safety recall for the 2011 Volvo XC90: Steering. Recall repairs are normally free at an authorized dealer.

What are the most common problems with the 2011 Volvo XC90?

Based on 19 owner complaints filed with NHTSA, the most-reported problem areas are Engine (5), Electrical System (5), Power Train (3).

How do I check if a recall on my 2011 Volvo XC90 has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.