CarRecallWatchThe 2015 Shasta Airflyte has 2 safety recalls on file with NHTSA.
Owners have filed 30 complaints with NHTSA.
The most-reported problem area is Unknown Or Other (14 reports).
2015 Shasta Airflyte recalls
Dinette Table Can Collapse Without Warning, Risking Injury
Certain 2015-2016 Shasta Airflyte travel trailers, built between April 28, 2015 and May 14, 2015, may have a dinette table that does not have adequate support when lowered on its supporting leg.
Incorrect tire and weight label can lead to tire failure
The Federal Certification Label on these travel trailers incorrectly lists the tire size, gross axle weight rating, gross vehicle weight rating and cargo carrying capacity.
Most common 2015 Shasta Airflyte problems
Problem areas named in the 30 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Unknown Or Other | 14 |
| Structure | 14 |
| Suspension | 8 |
| Wheels | 6 |
| Equipment | 2 |
| Electrical System | 2 |
| Exterior Lighting | 1 |
What owners report
The entire front panel of my Shasta Airflyte travel trailer is separating from the pine bracing where the dinette is, creating a 2â gap at the floor where rodents and water could get in. It appears the screws meant to attach the panel to the bracing are sheared off or improperly installed. The separating front panel is resting on the propane tank which could create a safety hazard. I believe there is a technical service bulletin issued from the manufacturer to address this defect, but it should be noted that this is still an ongoing problem. The trailer is available for inspection, but hasnât yet been seen by a dealer or insurance agent.
The Shasta Airflyte trailer is clad in aluminum metal sheathing called a skin. The metal skins on the doors are held by a rubber spline molding but no screws or fasteners. The trailer door needs a decent amount of force to open/close which creates some flex so the metal skin gets loose and had popped out over the spline in a couple places. I noticed it a couple months ago but shoved it back under the spline as intended, and that seemed to fix it. The spline molding seemed to be in normal working condition, there werenât obvious signs of wear or failure, I just think itâs a bad design and inadequate manufacturing. While I was driving down the road at maybe 40-50 mph, the bottom alumin
SEAMS ON THE EXTERIOR HAVE LEAKED ALLOWING WATER TO GET IN FROM DAY ONE. ELECTRICAL IN WALLS IS A POTENTIAL DANGER. SHASTA CLAIMS NO RESPONSIBILITY AND WILL NOT REPAIR ANY WATER DAMAGE.
2015 SHASTA AIRFLYTE. CONSUMER WRITE SIN REGARDS TO FAULTY DESIGN AND FRAME WELDING. *LD *TR *DT UPDATED 10/5/18*JB
CONCERNED THAT THE CHASSIS, FLOOR AND FRONT WALL MAY HAVE BEEN INCONSISTENTLY FASTENED TOGETHER. TSB: 53-0597 IN PLACE WITH 2 "KITS" RECOMMENDED. WITH RECOMMEND FIX I AM WORRIED ABOUT ALL THE WEIGHT AND TORQUE THAT WOULD BE APPLIED TO A BOLT ON FIX. SHASTA/FOREST RIVER SAID THAT A FLEXING FRAME IS OK AND GAPS ARE NORMAL. CONCERNED FOR MY SAFETY AND SAFETY OF OTHERS WHEN WE TOW. INFORMED OF PROBLEM APPROXIMATELY OCT. 2017. *BF *BF *TR
2015 Shasta Airflyte questions
Does the 2015 Shasta Airflyte have any recalls?
Yes. NHTSA lists 2 safety recalls for the 2015 Shasta Airflyte: Dinette Table Can Collapse Without Warning, Risking Injury; Incorrect tire and weight label can lead to tire failure. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 2015 Shasta Airflyte?
Based on 30 owner complaints filed with NHTSA, the most-reported problem areas are Unknown Or Other (14), Structure (14), Suspension (8).
How do I check if a recall on my 2015 Shasta Airflyte has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.