CarRecallWatchThe 1999 Rexhall Aerbus has 2 safety recalls on file with NHTSA.
Owners have filed 5 complaints with NHTSA.
The most-reported problem area is Power Train (3 reports).
1999 Rexhall Aerbus recalls
Most common 1999 Rexhall Aerbus problems
Problem areas named in the 5 complaints owners filed with NHTSA.
| Problem area | Reports |
|---|---|
| Power Train | 3 |
| Service Brakes, Hydraulic | 2 |
| Electrical System | 1 |
What owners report
BATTERY DISCONNECT FAILED WHILE DRIVING OUR 20,200 POUND RV AT HIGHWAY SPEED. THE FAILURE RESULTED IN TOTAL LOSS OF CHASSIS POWER (ENGINE STOPPED, POWER STEERING CEASED, POWER STEERING CEASED, ALL DASH INDICATORS NON-OPERATIONAL, EMERGENCY FLASHER NON-OPERATIONAL, ETC.). THE FAILURE CAUSED US TO COAST TO A STOP AS THERE WAS NOTHING ELSE WE COULD DO. THE FAILED PART WAS LATER IDENTIFIED AS: BATTERY DISCONNECT SOLENOID (INTELLITEC 01-00055-002 04098 BCC RELAY (PRINTED ON STICKER PLACED ON TOP PORTION OF UNIT), 612-12V 797 (PRINTED ON BOTTOM OF UNIT). THE BATTERY DISCONNECT SERVICE MANUAL, P/N 53-00066-100, REV B, 030905 FAILS TO LIST TOTAL LOSS OF POWER WHILE IN MOTION AS A POTENTIAL PROBL
DRIVESHAFT FAILED. *SLC
ANTI-LOCK BRAKING SYSTEM HAS CAUGHT OVERHEATED AND LOCKED UP A COUPLE OF TIMES. MASTER CYLINDER WAS REPLACED, BUT DID NOT STOP THE PROBLEMS. DEALER HAS BEEN CONTACTED. *AK
ON FORD CHASSIS, BOLT THAT HOLD THE DRIVELINE WHICH GOES INTO THE TRANSMISSION, SHEARED OFF WHICH MAY CAUSE A CRASH. *AK
FORD ENGINEER INSPECTION CONCLUDED THAT MANUFACTURER DID NOT FOLLOW FORD SPECIFICATIONS FOR EXTENDING CHASIS/ DRIVESHAFT WAS 3 INCHES TOO LONG AND NOT AT THE PROPER ANGLE. ALSO PARTS THAT SHOULD HAVE BEEN BOLTED WERE WELDED. I HAVE PROOF OF ALL THESE ALL. THE DRIVESHAFT FELL OFF ON THREE SEPARATE OCCASIONS DUE TO THIS DEFECT.
1999 Rexhall Aerbus questions
Does the 1999 Rexhall Aerbus have any recalls?
Yes. NHTSA lists 2 safety recalls for the 1999 Rexhall Aerbus: Equipment:Recreational Vehicle/Trailer; Power Train:Driveline:Driveshaft. Recall repairs are normally free at an authorized dealer.
What are the most common problems with the 1999 Rexhall Aerbus?
Based on 5 owner complaints filed with NHTSA, the most-reported problem areas are Power Train (3), Service Brakes, Hydraulic (2), Electrical System (1).
How do I check if a recall on my 1999 Rexhall Aerbus has been fixed?
Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.