2004 Mitsubishi Montero Sport Recalls, Problems & Safety Rating

2004 Mitsubishi Montero Sport recalls

Most common 2004 Mitsubishi Montero Sport problems

Problem areas named in the 5 complaints owners filed with NHTSA.

Problem area	Reports
Fuel/Propulsion System	2
Air Bags	1
Seat Belts	1
Power Train	1
Engine And Engine Cooling	1

What owners report

2015-11-19, Fuel/Propulsion System
FILL SUV WITH GAS AND IT ALL LEAKED OUT UNDER THE SUV.

2015-10-21, Fuel/Propulsion System
TL* THE CONTACT OWNS A 2004 MITSUBISHI MONTERO SPORT. THE CONTACT DETECTED THE ODOR OF FUEL IN THE VEHICLE. THE CONTACT STATED THAT THE FAILURE BECAME PROGRESSIVELY WORSE OVER TIME. AFTER FULLY REFUELING THE VEHICLE, IT BEGAN TO LEAK FUEL AT APPROXIMATELTY FOUR DROPS PER SECOND. THE CONTACT ALSO STATED THAT THE VEHICLE LEAKED FUEL WHEN PARKED ON INCLINES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 200,000.

2014-10-01, Engine And Engine Cooling
HEAT GAUGE IS FAULTY AND IT WILL BLOW HOT HEAT ONLY OUT OF DRIVER SIDE VENTS AND BLOWS COLD OUT OF THE REST OF THE VENTS. HEAT GAUGE SAYS ITS RUNNING FINE BUT IT IS REALLY OVERHEATING TO THE BOILING POINT. I AM NOT SURE HOW LONG IT HAS HAD THIS PROBLEM AS I JUST BOUGHT IT 2 WEEKS AGO AND HAVE HAD NO USE FOR THE HEAT TILL NOW AND NEVER DROVE IT FAR ENOUGH TILL TODAY WHEN I NOTICED THE HEAT GAUGE AND HEARD IT BOILING OVER WITH STEAM COMING OUT OF THE HOOD. *TR

2009-07-07, Power Train
2004 MITSUBISHI MONTERO SPORT I PURCHASED THE VEHICLE FROM DRIVETIME AND THE SERVICE ENGINE LIGHT CAME ON IMMEDIATELY. IT WENT OFF AFTER I TURNED IT OFF. 2 DAYS LATER THE A/T TEMP LIGHT CAME ON. THE 4H LIGHT CAME ON AND THE ANTI LOCK BRAKE LIGHT CAME ON. I CALLED THE WARRANTY COMPANY AND I WAS SENT TO A MECHANIC WHO REMOVED ALL THE ELECTRIC CONNECTORS AND PRONOUNCED THE CAR FIXED. 2 DAYS LATER THE A/T TEMP LIGHT CAME ON AGAIN I WAS SENT TO A TRANSMISSION SPECIALIST WHO CHANGED THE TRANSMISSION 2 WEEKS LATER THE LIGHT IS ON AGAIN ANYTIME I DRIVE MORE THAT 40 MILES. *TR

2006-01-05, Air Bags
DT*: THE CONTACT STATED WHILE DRIVING ON SLIPPERY ROADS THE CONSUMER HIT A PUDDLE AND ROLLED OVER A FENCE INTO A WATER RESERVE. UPON IMPACT, BOTH FRONTAL AIRBAGS FAILED TO DEPLOY AND THE DRIVER'S SEAT BELT FAILED. THE SEAT BELT CAME UNLATCHED WHILE THE VEHICLE ROLLED OVER THE FENCE. THE SEAT BELT WAS ABLE TO LATCH AFTER THE ACCIDENT. THE CONTACT SUSTAINED BACK AND NECK INJURIES ALONG WITH LOSS OF MOVEMENT TO THE HAND. DURING THE ACCIDENT, THE CONTACT'S KNEE HIT THE STEERING COLUMN BECAUSE OF THE SEAT BELT FAILURE. THE POLICE DETERMINED THE SPEED OF THE VEHICLE WAS 60 MPH AT THE TIME OF THE INCIDENT. *AK UPDATED 01/25/06. *JB

2004 Mitsubishi Montero Sport questions

Does the 2004 Mitsubishi Montero Sport have any recalls?

Yes. NHTSA lists 1 safety recall for the 2004 Mitsubishi Montero Sport: Equipment:Other:Labels. Recall repairs are normally free at an authorized dealer.

What are the most common problems with the 2004 Mitsubishi Montero Sport?

Based on 5 owner complaints filed with NHTSA, the most-reported problem areas are Fuel/Propulsion System (2), Air Bags (1), Seat Belts (1).

How do I check if a recall on my 2004 Mitsubishi Montero Sport has been fixed?

Enter your 17-character VIN in our VIN recall check. It shows open recalls that have not been repaired on your specific vehicle. Recall repairs are normally free at an authorized dealer.